- Critical: Demonstration of Knowledge* (corrected on site) (repeated violation)
Observation: The person in charge failed to explain the significance of the relationship between the holding time and temperature of potentially hazardous food and foodborne illness.
Correction: Ensure the designated person in charge (PIC) is knowledgeable about foodborne disease prevention, Hazardous Analysis Critical Control Point principles and Regulation requirements. The PIC should be prepared to recognize conditions that may contribute to foodborne illness. The PIC must also recognize conditions that fail to comply with Regulation requirements and be authorized to take the appropriate preventive and corrective actions to ensure that the Regulations' objectives are fulfilled.
- Critical: Demonstration of Knowledge* (corrected on site) (repeated violation)
Observation: The person in charge failed to explain the correct procedures for cleaning and sanitizing utensils and food-contact surfaces of equipment.
Correction: Ensure the designated person in charge (PIC) is knowledgeable about foodborne disease prevention, Hazardous Analysis Critical Control Point principles and Regulation requirements. The PIC should be prepared to recognize conditions that may contribute to foodborne illness. The PIC must also recognize conditions that fail to comply with Regulation requirements and be authorized to take the appropriate preventive and corrective actions to ensure that the Regulations' objectives are fulfilled.
- Person in Charge (corrected on site)
Observation: Food employees are not informed of their responsibility to report to their PIC information concerning their health and activities as they relate to diseases transmitted through food.
Correction: PIC is to advise employees of their responsibility to report in accordance with law information concerning their health and activities as they relate to diseases transmitted through food.
- Critical: Food - Packaged and Unpackaged - Separation, Packaging, and Segregation* (corrected on site) (repeated violation)
Observation: Different types of raw animal foods stored in such a manner that may cause cross contamination.
Correction: Separate types of raw animal foods from each other such as beef, fish, lamb pork, and poultry during storage, preparation, holding, and display by the following: (a) Using separate equipment for each type. (b) Arranging each type of food in equipment so that cross contamination of one type with another is prevented. (c) Preparing each type of food at different times or in separate areas.
- Food Storage Containers - Identified with Common Name of Food (repeated violation)
Observation: Unlabeled food containers.
Correction: Label working containers with the common name of its contents. Consumers may be allergic to certain foods or ingredients. The mistaken use of an ingredient when the consumer has requested that it not be used may result in severe medical consequences. Liquid foods and granular foods may resemble cleaning compounds. The mistaken use of food from an unlabeled container could result in chemical poisoning.
- Utensils - In-Use - Between-Use Storage (corrected on site)
Observation: In-use utensils improperly stored between use.
Correction: Store in-use utensils or dispensing utensils in one of the following manners: 1) In the food with their handles above the top of the food and the container. 2) In food that is not potentially hazardous with their handles above the top of the food within containers or equipment that can be closed. 3) On a clean portion of the food preparation table or cooking equipment only if the in-use utensil and the food-contact surface of the food preparation table or cooking equipment are cleaned and sanitized every 4 hours. 4) In running water of sufficient velocity to flush particulates to the drain. 5) In a clean, protected location if the utensils are used only with a food that is not potentially hazardous. 6) In a container of water if the water is maintained at a temperature of at least 135°F.
- Critical: Date Marking - Ready-to-Eat - Potentially Hazardous Food - Date Marking* (corrected on site)
Observation: The prepared cooked noodles in the refrigeration unit is not properly dated for disposition.
Correction: Mark the name and "consume by" date on the container of RTE foods at the time of preparation if the food is to be held for more than 24 hours. If the food is held at 41°F or below the food shall be served or sold within 7 calendar days. Some harmful bacteria continue to grow even at refrigeration temperatures so limiting the amount of time in storage limits the amount of growth allowed for these bacteria.
- Equipment - Food Contact Surfaces, Nonfood Contact Surfaces, and Utensils
Observation: Observed accumulations of dust, dirt, food residue or other debris on the following nonfood-food contact surfaces: Preparation table.
Correction: Maintain nonfood-contact surfaces of equipment clean.
- Handwashing - Using a Handwashing Lavatory - No Other Purpose (corrected on site)
Observation: The handwash station in the kitchen is being used as a dump station.
Correction: The handwash facility identified above is to be used for washing hands only
- Critical: Plumbing System Maintained in Good Repair
Observation: The sink basin at the hand sink is slow to drain.
Correction: Plumbing systems and components shall be maintained in good repair.
- Physical Facilities - Cleaning Frequency and Restrictions (repeated violation)
Observation: Floors and walls in the kitchen noted in need of cleaning.
Correction: All floors, walls, and ceilings must be cleaned as often as necessary to keep them clean. Cleaning of the physical facilities is an important measure in ensuring the protection and sanitary preparation of food. A regular cleaning schedule should be established and followed to maintain the facility in a clean and sanitary manner.
- Premises - Maintaining Premises - Unnecessary Items and Litter (repeated violation)
Observation: Premises has accumulation of litter
Correction: Maintain the premise free of litter.
|
01/29/2016 | Routine | |
- Equipment - Food Contact Surfaces, Nonfood Contact Surfaces, and Utensils (repeated violation)
Observation: Observed accumulations of encrusted grease deposits or other soil on the following food contact surfaces: Preparation table.
Correction: Clean and sanitize these surfaces for food contact.
- Physical Facilities in Good Repair (repeated violation)
Observation: Wall at the three compartment sink is not maintained in good repair.
Correction: Maintain physical facilities in good repair. Poor repair and maintenance compromises the functionality of the physical facilities.
- Physical Facilities - Cleaning Frequency and Restrictions (repeated violation)
Observation: Floors in the kitchen noted in need of cleaning.
Correction: All floors, walls, and ceilings must be cleaned as often as necessary to keep them clean. Cleaning of the physical facilities is an important measure in ensuring the protection and sanitary preparation of food. A regular cleaning schedule should be established and followed to maintain the facility in a clean and sanitary manner.
- Premises - Maintaining Premises - Unnecessary Items and Litter (repeated violation)
Observation: Facility is storing unnecessary items to the operation or maintenance of the establishment.
Correction: Remove all unnecessary items from the facility. The presence of unnecessary articles, including equipment which is no longer used, makes regular and effective cleaning more difficult and less likely. It can also provide harborage for insects and rodents.
|
10/27/2015 | Follow-up | |
- Critical: Demonstration of Knowledge* (corrected on site) (repeated violation)
Observation: The person in charge failed to identify Critical Control Points (CCP) in the operation from purchasing through sale or service. The PIC is not aware of the relationship between controlling CCPs and the transmission of foodborne illness.
Correction: Ensure the designated person in charge (PIC) is knowledgeable about foodborne disease prevention, Hazardous Analysis Critical Control Point principles and Regulation requirements. The PIC should be prepared to recognize conditions that may contribute to foodborne illness. The PIC must also recognize conditions that fail to comply with Regulation requirements and be authorized to take the appropriate preventive and corrective actions to ensure that the Regulations' objectives are fulfilled.
- Critical: Food - Packaged and Unpackaged - Separation, Packaging, and Segregation* (corrected on site) (repeated violation)
Observation: Different types of raw animal foods stored in such a manner that may cause cross contamination.
Correction: Separate types of raw animal foods from each other such as beef, fish, lamb pork, and poultry during storage, preparation, holding, and display by the following: (a) Using separate equipment for each type. (b) Arranging each type of food in equipment so that cross contamination of one type with another is prevented. (c) Preparing each type of food at different times or in separate areas.
- Cloths - Wiping Cloths - Use Limitation (corrected on site) (repeated violation)
Observation: Wiping cloths improperly stored between use.
Correction: Ensure wet wiping cloths are stored in a chemical sanitizer at the proper concentration between use.
- Critical: Time as a Public Health Control* (corrected on site)
Observation: Chicken and egg rolls for which time rather than temperature is being used as a control was not labeled or otherwise marked with a 4 hour cook, serve or discard by time.
Correction: Discard food that is not cooked and served or served if ready-to-eat within 4 hours from the point in time when the food is removed from temperature control. Clearly label or otherwise mark the food with a 4-hour cook-serve or serve by time.
- Nonfood-Contact Surfaces - Corrosion Resistant/Nonabsorbent (corrected on site)
Observation: The nonfood contact surface of the paper towels used to store clean utensils is not corrosion resistant, nonabsorbent, and/or smooth.
Correction: Nonfood contact equipment that is exposed to splash, spillage, food soiling, or requires frequent cleaning must be smooth, durable, and nonabsorbent.
- Equipment - Food Contact Surfaces, Nonfood Contact Surfaces, and Utensils (repeated violation)
Observation: Observed accumulations of encrusted grease deposits or other soil on the following food contact surfaces: Preparation table.
Correction: Clean and sanitize these surfaces for food contact.
- Handwashing - Using a Handwashing Lavatory (corrected on site)
Observation: The handwashing facility located at the kitchen is blocked, preventing access by employees for easy handwashing.
Correction: Access to the handwashing facility identified above is to be available during all hours of operation. Remove the equipment preventing its use.
- Critical: Plumbing System Maintained in Good Repair
Observation: Plumbing connections under the three compartment sink are missing.
Correction: Plumbing systems and components shall be maintained in good repair.
- Physical Facilities in Good Repair
Observation: Wall at the three compartment sink is not maintained in good repair.
Correction: Maintain physical facilities in good repair. Poor repair and maintenance compromises the functionality of the physical facilities.
- Physical Facilities - Cleaning Frequency and Restrictions (repeated violation)
Observation: Floors in the kitchen noted in need of cleaning.
Correction: All floors, walls, and ceilings must be cleaned as often as necessary to keep them clean. Cleaning of the physical facilities is an important measure in ensuring the protection and sanitary preparation of food. A regular cleaning schedule should be established and followed to maintain the facility in a clean and sanitary manner.
- Premises - Maintaining Premises - Unnecessary Items and Litter
Observation: Facility is storing unnecessary items to the operation or maintenance of the establishment.
Correction: Remove all unnecessary items from the facility. The presence of unnecessary articles, including equipment which is no longer used, makes regular and effective cleaning more difficult and less likely. It can also provide harborage for insects and rodents.
- Critical: Animals - Prohibiting Animals* (corrected on site)
Observation: Turtles were noted in the establishment.
Correction: Prohibit all live animals on the premises of the food establishment. Animals carry disease-causing organisms and can transmit pathogens to humans through direct and/or indirect contamination of food and food-contact surfaces. Animals shed hair continuously and may deposit liquid or fecal waste, creating the need for vigilance and more frequent and rigorous cleaning effort.
- Toxics - Presence and Use Restriction (corrected on site)
Observation: Unnecessary poisonous or toxic materials found in the food establishment.
Correction: Remove unnecessary poisonous or toxic materials.
|
10/20/2015 | Routine | |
- Food Storage Containers - Identified with Common Name of Food (repeated violation)
Observation: Unlabeled food containers. Food at cook area.
Correction: Label working containers with the common name of its contents. Consumers may be allergic to certain foods or ingredients. The mistaken use of an ingredient when the consumer has requested that it not be used may result in severe medical consequences. Liquid foods and granular foods may resemble cleaning compounds. The mistaken use of food from an unlabeled container could result in chemical poisoning.
- Food Storage - Clean and Dry Location (repeated violation)
Observation: Food stored on the floor or food stored less than 6" above the floor inside the walk-in refrigerator.;Elevate food storage onto approved shelving with minimum 6" legs or casters.
- Physical Facilities - Cleaning Frequency and Restrictions (repeated violation)
Observation: Floors and walls in the kitchen noted in need of cleaning.
Correction: All floors, walls, and ceilings must be cleaned as often as necessary to keep them clean. Cleaning of the physical facilities is an important measure in ensuring the protection and sanitary preparation of food. A regular cleaning schedule should be established and followed to maintain the facility in a clean and sanitary manner.
|
06/30/2015 | Follow-up | |
- Critical: Demonstration of Knowledge* (repeated violation)
Observation: The person in charge failed to explain the correct procedures for cleaning and sanitizing utensils and food-contact surfaces of equipment.
Correction: Ensure the designated person in charge (PIC) is knowledgeable about foodborne disease prevention, Hazardous Analysis Critical Control Point principles and Regulation requirements. The PIC should be prepared to recognize conditions that may contribute to foodborne illness. The PIC must also recognize conditions that fail to comply with Regulation requirements and be authorized to take the appropriate preventive and corrective actions to ensure that the Regulations' objectives are fulfilled.
- Critical: Demonstration of Knowledge* (repeated violation)
Observation: The person in charge failed to explain the relationship between food safety and providing equipment that is: (a) Sufficient in number and capacity, and (b) Properly designed, constructed, located, installed, operated, and cleaned.
Correction: Ensure the designated person in charge (PIC) is knowledgeable about foodborne disease prevention, Hazardous Analysis Critical Control Point principles and Regulation requirements. The PIC should be prepared to recognize conditions that may contribute to foodborne illness. The PIC must also recognize conditions that fail to comply with Regulation requirements and be authorized to take the appropriate preventive and corrective actions to ensure that the Regulations' objectives are fulfilled.
- Critical: Food - Packaged and Unpackaged - Separation, Packaging, and Segregation* (corrected on site) (repeated violation)
Observation: Different types of raw animal foods stored in such a manner that may cause cross contamination. Raw chicken stored over raw beef.
Correction: Separate types of raw animal foods from each other such as beef, fish, lamb pork, and poultry during storage, preparation, holding, and display by the following: (a) Using separate equipment for each type. (b) Arranging each type of food in equipment so that cross contamination of one type with another is prevented. (c) Preparing each type of food at different times or in separate areas.
- Food Storage Containers - Identified with Common Name of Food
Observation: Unlabeled food containers. Food at cook area.
Correction: Label working containers with the common name of its contents. Consumers may be allergic to certain foods or ingredients. The mistaken use of an ingredient when the consumer has requested that it not be used may result in severe medical consequences. Liquid foods and granular foods may resemble cleaning compounds. The mistaken use of food from an unlabeled container could result in chemical poisoning.
- Cloths - Wiping Cloths - Use Limitation (corrected on site)
Observation: Improper use of wet wiping cloths.
Correction: Use clean wet wiping cloths for wiping spills from food-contact and nonfood-contact surfaces of equipment. Store wet wiping in a chemical sanitizer at the proper concentration between use.
- Food Storage - Clean and Dry Location
Observation: Food stored on the floor or food stored less than 6" above the floor inside the walk-in refrigerator.;Elevate food storage onto approved shelving with minimum 6" legs or casters.
- Critical: Cooling* (corrected on site)
Observation: Cooked rice noted not being adequately cooled to prevent the growth of harmful bacteria.
Correction: Cool potentially hazardous foods from 135°F to 70°F within 2 hours and within a total of 6 hours from 135°F to 41°F. A longer time for cooling allows an ideal situation for bacterial growth. This has been shown to be the major contributing factor in many foodborne illnesses.
- Critical: Food - Potentially Hazardous Food - Cold Holding* (corrected on site) (repeated violation)
Observation: Cooked pork, pork wanton, raw beef, and raw chicken cold holding at improper temperatures
Correction: Discard the food and ensure that potentially hazardous foods for cold holding are maintained at 41°F or below to inhibit the growth of harmful bacteria.
- Critical: Equipment - Food Contact Surfaces, Nonfood Contact Surfaces, and Utensils* (corrected on site)
Observation: The following equipment food-contact surfaces were observed soiled to sight and touch: Pans used to store food in the preparation table rinsed and placed back in the preparation table.
Correction: Clean and sanitize these surfaces for food contact.
- Critical: Equipment and Utensils - Before Use After Cleaning*
Observation: The food-contact surfaces of the following equipment were not observed sanitized: No chemical sanitizer present when checking the mechanical dish machine.
Correction: After cleaning and rinsing of the food-contact surface, the surface shall be effectively sanitized before coming in contact with food and before use.
- Physical Facilities - Cleaning Frequency and Restrictions (repeated violation)
Observation: Floors and walls in the kitchen noted in need of cleaning.
Correction: All floors, walls, and ceilings must be cleaned as often as necessary to keep them clean. Cleaning of the physical facilities is an important measure in ensuring the protection and sanitary preparation of food. A regular cleaning schedule should be established and followed to maintain the facility in a clean and sanitary manner.
|
06/18/2015 | Routine | |
- Physical Facilities - Cleaning Frequency and Restrictions (repeated violation)
Observation: Floors, walls, and ceiling in the kitchen noted in need of cleaning.
Correction: All floors, walls, and ceilings must be cleaned as often as necessary to keep them clean. Cleaning of the physical facilities is an important measure in ensuring the protection and sanitary preparation of food. A regular cleaning schedule should be established and followed to maintain the facility in a clean and sanitary manner.
|
03/31/2015 | Follow-up | |
- Critical: Demonstration of Knowledge* (corrected on site) (repeated violation)
Observation: The person in charge failed to explain the relationship between food safety and providing equipment that is: (a) Sufficient in number and capacity, and (b) Properly designed, constructed, located, installed, operated, and cleaned.
Correction: Ensure the designated person in charge (PIC) is knowledgeable about foodborne disease prevention, Hazardous Analysis Critical Control Point principles and Regulation requirements. The PIC should be prepared to recognize conditions that may contribute to foodborne illness. The PIC must also recognize conditions that fail to comply with Regulation requirements and be authorized to take the appropriate preventive and corrective actions to ensure that the Regulations' objectives are fulfilled.
- Critical: Demonstration of Knowledge* (corrected on site) (repeated violation)
Observation: The person in charge failed to explain the correct procedures for cleaning and sanitizing utensils and food-contact surfaces of equipment.
Correction: Ensure the designated person in charge (PIC) is knowledgeable about foodborne disease prevention, Hazardous Analysis Critical Control Point principles and Regulation requirements. The PIC should be prepared to recognize conditions that may contribute to foodborne illness. The PIC must also recognize conditions that fail to comply with Regulation requirements and be authorized to take the appropriate preventive and corrective actions to ensure that the Regulations' objectives are fulfilled.
- Person in Charge
Observation: Food employees are not informed of their responsibility to report to their PIC information concerning their health and activities as they relate to diseases transmitted through food.
Correction: PIC is to advise employees of their responsibility to report in accordance with law information concerning their health and activities as they relate to diseases transmitted through food.
- Critical: Food - Packaged and Unpackaged - Separation, Packaging, and Segregation* (corrected on site) (repeated violation)
Observation: Raw food of animal origin holding in a manner that may cause cross contamination of to ready-to-eat food (RTE).
Correction: Separate raw foods during storage, preparation, holding, and display from raw RTE food including other raw food such as fish for sushi or molluscan shellfish, or other raw RTE food such as vegetables, and cooked RTE food.
- Food - Packaged and Unpackaged - Separation, Packaging, and Segregation (corrected on site)
Observation: Observed that food was not protected from cross-contamination because it was not in packages, covered containers, or wrapped.
Correction: Prevent cross-contamination by storing food in packages, covered containers, or wrappings.
- Critical: Food - Potentially Hazardous Food - Cold Holding* (corrected on site)
Observation: Cooked noodles and wantons cold holding at improper temperatures.
Correction: Discard the food and ensure that potentially hazardous foods for cold holding are maintained at 41°F or below to inhibit the growth of harmful bacteria.
- Critical: Date Marking - Ready-to-Eat - Potentially Hazardous Food - Date Marking* (corrected on site) (repeated violation)
Observation: The prepared food in the preparation table and walk-in refrigerator is not properly dated for disposition.
Correction: Mark the name and "consume by" date on the container of RTE foods at the time of preparation if the food is to be held for more than 24 hours. If the food is held at 41°F or below the food shall be served or sold within 7 calendar days. Some harmful bacteria continue to grow even at refrigeration temperatures so limiting the amount of time in storage limits the amount of growth allowed for these bacteria.
- Equipment and Utensils - Multiuse, Characteristics (corrected on site)
Observation: The food contact surface of the metal trash can and cardboard boxes are not durable, nonabsorbent, easily cleanable, resistant to pitting.
Correction: Replace the trash can and cardboard boxes to permit easy cleaning and prevent the migration of deleterious substances, or transference of colors, odors, or tastes to food.
- Equipment - Food Contact Surfaces, Nonfood Contact Surfaces, and Utensils
Observation: Observed accumulations of encrusted grease deposits or other soil on the following food contact surfaces: Preparation table.
Correction: Clean and sanitize these surfaces for food contact.
- Critical: Equipment and Utensils - Before Use After Cleaning* (corrected on site) (repeated violation)
Observation: The food-contact surfaces of the following equipment were not observed sanitized: Pots and pans at the three compartment sink.
Correction: After cleaning and rinsing of the food-contact surface, the surface shall be effectively sanitized before coming in contact with food and before use.
- Critical: Plumbing System Maintained in Good Repair
Observation: Plumbing connections under the dish machine are leaking. Water running out onto the floor.
Correction: Plumbing systems and components shall be maintained in good repair.
- Physical Facilities - Cleaning Frequency and Restrictions (repeated violation)
Observation: Floors, walls, and ceiling in the kitchen noted in need of cleaning.
Correction: All floors, walls, and ceilings must be cleaned as often as necessary to keep them clean. Cleaning of the physical facilities is an important measure in ensuring the protection and sanitary preparation of food. A regular cleaning schedule should be established and followed to maintain the facility in a clean and sanitary manner.
|
03/26/2015 | Routine | |
- Critical: Demonstration of Knowledge* (repeated violation)
Observation: The person in charge failed to state the required temperatures and holding times for the following conditions of potentially hazardous food: (1) Refrigerated storage, (2) Hot holding, (3) Cooling, and (4) Reheating.
Correction: Ensure the designated person in charge (PIC) is knowledgeable about foodborne disease prevention, Hazardous Analysis Critical Control Point principles and Regulation requirements. The PIC should be prepared to recognize conditions that may contribute to foodborne illness. The PIC must also recognize conditions that fail to comply with Regulation requirements and be authorized to take the appropriate preventive and corrective actions to ensure that the Regulations' objectives are fulfilled.
- Critical: Demonstration of Knowledge* (repeated violation)
Observation: The person in charge failed to identify Critical Control Points (CCP) in the operation from purchasing through sale or service. The PIC is not aware of the relationship between controlling CCPs and the transmission of foodborne illness.
Correction: Ensure the designated person in charge (PIC) is knowledgeable about foodborne disease prevention, Hazardous Analysis Critical Control Point principles and Regulation requirements. The PIC should be prepared to recognize conditions that may contribute to foodborne illness. The PIC must also recognize conditions that fail to comply with Regulation requirements and be authorized to take the appropriate preventive and corrective actions to ensure that the Regulations' objectives are fulfilled.
- Critical: Demonstration of Knowledge* (repeated violation)
Observation: The person in charge failed to explain the significance of the relationship between the holding time and temperature of potentially hazardous food and foodborne illness.
Correction: Ensure the designated person in charge (PIC) is knowledgeable about foodborne disease prevention, Hazardous Analysis Critical Control Point principles and Regulation requirements. The PIC should be prepared to recognize conditions that may contribute to foodborne illness. The PIC must also recognize conditions that fail to comply with Regulation requirements and be authorized to take the appropriate preventive and corrective actions to ensure that the Regulations' objectives are fulfilled.
- Critical: Demonstration of Knowledge* (repeated violation)
Observation: The person in charge failed to explain the correct procedures for cleaning and sanitizing utensils and food-contact surfaces of equipment.
Correction: Ensure the designated person in charge (PIC) is knowledgeable about foodborne disease prevention, Hazardous Analysis Critical Control Point principles and Regulation requirements. The PIC should be prepared to recognize conditions that may contribute to foodborne illness. The PIC must also recognize conditions that fail to comply with Regulation requirements and be authorized to take the appropriate preventive and corrective actions to ensure that the Regulations' objectives are fulfilled.
- Critical: Employee Health* (repeated violation)
Observation: Employees or applicants are not aware of the reporting procedures concerning information about their health and activities as they relate to diseases that are transmissible through food, including the date of onset of jaundice or of an illness due to Salmonella Typhi, Shigella spp., Escherichia coli O157:H7, Hepatitis A virus or Norovirus
Correction: Have the license holder require employees or applicants report to the person in charge any information about their health and activities if they are diagnosed with or had a past illness from Salmonella Typhi, Shigella spp., Escherichia coli O157:H7, Hepatitis A virus or Norovirus
- Critical: Hands and Arms - Clean condition* (corrected on site)
Observation: Food employees observed with soiled hands and arms.
Correction: Inform all food employees to keep their hands and exposed portions of their arms clean.
- Critical: Food - Packaged and Unpackaged - Separation, Packaging, and Segregation* (corrected on site) (repeated violation)
Observation: Raw food of animal origin holding in a manner that may cause cross contamination of to ready-to-eat food (RTE).
Correction: Separate raw foods during storage, preparation, holding, and display from raw RTE food including other raw food such as fish for sushi or molluscan shellfish, or other raw RTE food such as vegetables, and cooked RTE food.
- Thawing (corrected on site)
Observation: Improper methods used to thaw shrimp, beef, and chicken. Items left out at room temperature.
Correction: Thaw potentially hazardous foods by either of the following methods: 1. Under refrigeration that maintains food temperature at 41°F (45°F) 2. Completely submerged under running water at a temperature of 70°F or below with sufficient water velocity to agitate and float off loose particles in an overflow. Ready-to-eat food shall not exceed 41°F and raw animal foods shall not exceed 41°F for more than four hours 3. As part of the cooking process
- Critical: Date Marking - Ready-to-Eat - Potentially Hazardous Food - Date Marking* (corrected on site)
Observation: The prepared noodles in the refrigeration unit is not properly dated for disposition.
Correction: Mark the name and "consume by" date on the container of RTE foods at the time of preparation if the food is to be held for more than 24 hours. If the food is held at 41°F or below the food shall be served or sold within 7 calendar days. Some harmful bacteria continue to grow even at refrigeration temperatures so limiting the amount of time in storage limits the amount of growth allowed for these bacteria.
- Critical: Time as a Public Health Control* (corrected on site)
Observation: Cooked chicken for which time rather than temperature is being used as a control was not labeled or otherwise marked with a 4 hour cook, serve or discard by time.
Correction: Discard food that is not cooked and served or served if ready-to-eat within 4 hours from the point in time when the food is removed from temperature control. Clearly label or otherwise mark the food with a 4-hour cook-serve or serve by time.
- Critical: Time as a Public Health Control* (corrected on site)
Observation: No written procedures for the use of time as a public health control with potentially hazardous foods.
Correction: Provide written procedures for the use of time as a public health control. The procedures must include the following steps or practices: a. Food must be marked with the time within which it must be cooked, served or discarded. b. The food is served or discarded within four hours from the time when the food is removed from temperature control c. Food in unmarked containers or packages, or for which the time expires is discarded and d. Written procedures are maintained in the food establishment and made available to the regulatory authority upon request e. Once time is implemented as a control measure for potentially hazardous food, no other measures may be substituted.
- Handwashing - Using a Handwashing Lavatory (corrected on site) (repeated violation)
Observation: The handwashing facility located in the kitchen is blocked, preventing access by employees for easy handwashing. Observed a frozen package of shrimp in the sink and a trash container in front of the sink.
Correction: Access to the handwashing facility identified above is to be available during all hours of operation. Remove the food and trash container preventing its use.
- Physical Facilities - Cleaning Frequency and Restrictions (repeated violation)
Observation: Floors, walls, and ceilings in the kitchen noted in need of cleaning.
Correction: All floors, walls, and ceilings must be cleaned as often as necessary to keep them clean. Cleaning of the physical facilities is an important measure in ensuring the protection and sanitary preparation of food. A regular cleaning schedule should be established and followed to maintain the facility in a clean and sanitary manner.
|
03/21/2014 | Routine | |
- Critical: Food - Packaged and Unpackaged - Separation, Packaging, and Segregation* (corrected on site) (repeated violation)
Observation: Different types of raw animal foods stored in such a manner that may cause cross contamination.
Correction: Separate types of raw animal foods from each other such as beef, fish, lamb pork, and poultry during storage, preparation, holding, and display by the following: (a) Using separate equipment for each type. (b) Arranging each type of food in equipment so that cross contamination of one type with another is prevented. (c) Preparing each type of food at different times or in separate areas.
- Critical: Equipment and Utensils - Before Use After Cleaning* (corrected on site) (repeated violation)
Observation: The food-contact surfaces of the following equipment were not observed sanitized: Equipment cleaned in the dishmachine.
Correction: After cleaning and rinsing of the food-contact surface, the surface shall be effectively sanitized before coming in contact with food and before use.
|
12/05/2013 | Follow-up | |
- Critical: Demonstration of Knowledge* (corrected on site) (repeated violation)
Observation: The person in charge failed to explain the correct procedures for cleaning and sanitizing utensils and food-contact surfaces of equipment.
Correction: Ensure the designated person in charge (PIC) is knowledgeable about foodborne disease prevention, Hazardous Analysis Critical Control Point principles and Regulation requirements. The PIC should be prepared to recognize conditions that may contribute to foodborne illness. The PIC must also recognize conditions that fail to comply with Regulation requirements and be authorized to take the appropriate preventive and corrective actions to ensure that the Regulations' objectives are fulfilled.
- Critical: Demonstration of Knowledge* (corrected on site) (repeated violation)
Observation: The person in charge failed to explain the significance of the relationship between the holding time and temperature of potentially hazardous food and foodborne illness.
Correction: Ensure the designated person in charge (PIC) is knowledgeable about foodborne disease prevention, Hazardous Analysis Critical Control Point principles and Regulation requirements. The PIC should be prepared to recognize conditions that may contribute to foodborne illness. The PIC must also recognize conditions that fail to comply with Regulation requirements and be authorized to take the appropriate preventive and corrective actions to ensure that the Regulations' objectives are fulfilled.
- Critical: Demonstration of Knowledge* (corrected on site) (repeated violation)
Observation: The person in charge failed to state the required temperatures and holding times for the following conditions of potentially hazardous food: (1) Refrigerated storage, (2) Hot holding, (3) Cooling, and (4) Reheating.
Correction: Ensure the designated person in charge (PIC) is knowledgeable about foodborne disease prevention, Hazardous Analysis Critical Control Point principles and Regulation requirements. The PIC should be prepared to recognize conditions that may contribute to foodborne illness. The PIC must also recognize conditions that fail to comply with Regulation requirements and be authorized to take the appropriate preventive and corrective actions to ensure that the Regulations' objectives are fulfilled.
- Critical: Employee Health*
Observation: Employees or applicants are not aware of the reporting procedures concerning information about their health and activities if they are suspected of causing, or being exposed to a confirmed disease outbreak caused by Salmonella Typhi, Shigella spp., Escherichia coli O157:H7, Hepatitis A virus or Norovirus
Correction: Have the license holder require employees or applicants report to the person in charge if they meet one or more of the following high-risk conditions: Is suspected of causing, or being exposed to, a confirmed disease outbreak caused by S. Typhi, Shigella, Escherichia coli O157:H7, Hepatitis A virus or norovirus
- Critical: Hands - When to Wash* (corrected on site)
Observation: A food employee failed to wash his or her hands before engaging in food preparation after engaging in any activity which may have contaminated his/her hands.
Correction: Instruct food employees to clean their hands and exposed portions of their arms immediately before engaging in food preparation including working with exposed food, clean equipment and utensils, and unwrapped single-service and single-use articles and during food preparation, as often as necessary to remove soil and contamination and to prevent cross contamination when changing task.
- Hair Restraints - Effectiveness (corrected on site) (repeated violation)
Observation: Employees observed working in the food service area without proper hair restraints.
Correction: Ensure all employees wear hair restraints such as hats, hair coverings or nets, beard restraints, and clothing that covers body hair, that are designed and worn to effectively keep their hair from contacting exposed food, clean equipment, utensils and linens, and unwrapped single-service and single-use articles. This section does not apply to food employees such as counter staff who only serve beverages and wrapped or packaged foods, hostesses, and wait staff if they present a minimal risk of contaminating exposed food
- Critical: Food - Packaged and Unpackaged - Separation, Packaging, and Segregation* (corrected on site) (repeated violation)
Observation: Different types of raw animal foods stored in such a manner that may cause cross contamination.
Correction: Separate types of raw animal foods from each other such as beef, fish, lamb pork, and poultry during storage, preparation, holding, and display by the following: (a) Using separate equipment for each type. (b) Arranging each type of food in equipment so that cross contamination of one type with another is prevented. (c) Preparing each type of food at different times or in separate areas.
- Food Storage Containers - Identified with Common Name of Food (repeated violation)
Observation: Unlabeled food containers.
Correction: Label working containers with the common name of its contents. Consumers may be allergic to certain foods or ingredients. The mistaken use of an ingredient when the consumer has requested that it not be used may result in severe medical consequences. Liquid foods and granular foods may resemble cleaning compounds. The mistaken use of food from an unlabeled container could result in chemical poisoning.
- Utensils - In-Use - Between-Use Storage (corrected on site) (repeated violation)
Observation: In-use utensils improperly stored between use.
Correction: Store in-use utensils or dispensing utensils in one of the following manners: 1) In the food with their handles above the top of the food and the container. 2) In food that is not potentially hazardous with their handles above the top of the food within containers or equipment that can be closed. 3) On a clean portion of the food preparation table or cooking equipment only if the in-use utensil and the food-contact surface of the food preparation table or cooking equipment are cleaned and sanitized every 4 hours. 4) In running water of sufficient velocity to flush particulates to the drain. 5) In a clean, protected location if the utensils are used only with a food that is not potentially hazardous. 6) In a container of water if the water is maintained at a temperature of at least 135°F.
- Cloths - Wiping Cloths - Use Limitation (corrected on site) (repeated violation)
Observation: Improper use of wet wiping cloths.
Correction: Use clean wet wiping cloths for wiping spills from food-contact and nonfood-contact surfaces of equipment. Store wet wiping in a chemical sanitizer at the proper concentration between use.
- Cooling Methods (corrected on site)
Observation: Food containers for cooling food are arranged so as not allow for maximum heat transfer.
Correction: Arrange the food containers in the refrigeration equipment to provide maximum heat transfer through the container walls. Loosely cover or uncover the food if protected from overhead contamination during the cooling period to facilitate heat transfer from the surface of the food.
- Critical: Food - Potentially Hazardous Food - Hot Holding* (corrected on site) (repeated violation)
Observation: Rice, egg rolls, and chicken hot holding at improper temperatures.
Correction: Rapidly reheat the food to 165°F and maintain at 135°F or above through the hot holding period.
- Sanitizing Solutions, Testing Devices
Observation: There is no properly working test kit provided in the facility for monitoring the concentration of the chemical sanitizing solutions.
Correction: Obtain a Chlorine test kit so that employees can accurately monitor the concentration of the sanitizing solutions and maintain them at a safe and effective level.
- Equipment - Cutting Surfaces
Observation: The cutting board(s) along the @LOCATION@ are heavily scratched and scored. The food contact surface is no longer easily cleaned and sanitized due to condition.
Correction: Resurface or discard and replace the cutting boards to provide a food contact surface that is smooth, easily cleaned and sanitized.
- Critical: Equipment and Utensils - Before Use After Cleaning* (corrected on site)
Observation: The food-contact surfaces of the following equipment were not observed sanitized: Pot at 3-compartment sink was not sanitized. Dishes run through dishmachine not sanitized.
Correction: After cleaning and rinsing of the food-contact surface, the surface shall be effectively sanitized before coming in contact with food and before use.
- Handwashing - Using a Handwashing Lavatory (corrected on site) (repeated violation)
Observation: The handwashing facility located at the kitchen is blocked, preventing access by employees for easy handwashing.
Correction: Access to the handwashing facility identified above is to be available during all hours of operation. Remove the equipment preventing its use.
- Physical Facilities - Cleaning Frequency and Restrictions (repeated violation)
Observation: Floors, walls, and ceilings in the kitchen noted in need of cleaning.
Correction: All floors, walls, and ceilings must be cleaned as often as necessary to keep them clean. Cleaning of the physical facilities is an important measure in ensuring the protection and sanitary preparation of food. A regular cleaning schedule should be established and followed to maintain the facility in a clean and sanitary manner.
|
11/22/2013 | Routine | |
Restaurant representatives - add corrected or new information about Shang Hai, 711 State Street, Bristol, VA 24201 »