Continue consistent date marking practices in addition to keeping food covered in all units. Replace damaged ceiling tiles over the water heater. Place a label with the list of allergens used as ingredients in the almond cookies.
- Critical: Food - Packaged and Unpackaged - Separation, Packaging, and Segregation* (corrected on site) (repeated violation)
Observation: Unwrapped or uncovered food in multiple refrigeration units.
Correction: Protect food from cross contamination by storing food in packages, covered containers, or wrappings.
- Food Storage Containers - Identified with Common Name of Food (repeated violation)
Observation: Unlabeled food containers.
Correction: Label working containers with the common name of its contents. Consumers may be allergic to certain foods or ingredients. The mistaken use of an ingredient when the consumer has requested that it not be used may result in severe medical consequences. Liquid foods and granular foods may resemble cleaning compounds. The mistaken use of food from an unlabeled container could result in chemical poisoning.
- Utensils - In-Use - Between-Use Storage (corrected on site) (repeated violation)
Observation: Dispensing utensils improperly stored between uses.
Correction: Store in-use utensils or dispensing utensils in one of the following manners: 1) In the food with their handles above the top of the food and the container. 2) In food that is not potentially hazardous with their handles above the top of the food within containers or equipment that can be closed. 3) On a clean portion of the food preparation table or cooking equipment only if the in-use utensil and the food-contact surface of the food preparation table or cooking equipment are cleaned and sanitized every 4 hours. 4) In running water of sufficient velocity to flush particulates to the drain. 5) In a clean, protected location if the utensils are used only with a food that is not potentially hazardous. 6) In a container of water if the water is maintained at a temperature of at least 135°F.
- Critical: Date Marking - Ready-to-Eat - Potentially Hazardous Food - Date Marking* (corrected on site) (repeated violation)
Observation: The prepared ready-to-eat (RTE) foods in multiple refrigeration units are not properly dated for disposition.
Correction: Mark the name and "consume by" date on the container of RTE foods at the time of preparation if the food is to be held for more than 24 hours. If the food is held at 41°F or below the food shall be served or sold within 7 calendar days. Some harmful bacteria continue to grow even at refrigeration temperatures so limiting the amount of time in storage limits the amount of growth allowed for these bacteria.
- Critical: Galvanized Metal, Use limitations*
Observation: Multiple galvanized cans are being used is being used in contact with acidic foods.
Correction: Discontinue use of galvanized metal as a food contact surface with acidic foods to prevent heavy metal contamination.
- Equipment - Food Contact Surfaces, Nonfood Contact Surfaces, and Utensils (repeated violation)
Observation: Observed accumulations of dust, dirt, food residue or other debris on the following non food contact surfaces: All surfaces of fryer station, exterior of all refrigeration units, interior of walk in cooler (floor and wire racks), all shelving used for storage...etc
Correction: Maintain non food contact surfaces of equipment clean.
- Physical Facilities - Cleaning Frequency and Restrictions (repeated violation)
Observation: Floors throughout the facility noted in need of cleaning.
Correction: All floors, walls, and ceilings must be cleaned as often as necessary to keep them clean. Cleaning of the physical facilities is an important measure in ensuring the protection and sanitary preparation of food. A regular cleaning schedule should be established and followed to maintain the facility in a clean and sanitary manner.
|
03/22/2016 | Routine | |
This was a follow-up inspection in response to a permit inspection conducted on 12/21/2015. Previous violations corrected. Spoke with the CFM regarding the following: 1) Implement a consistent practice of date marking and covering food in refrigeration units 2) Service order for cleaning vent filters provided to health inspector
- Critical: Food - Packaged and Unpackaged - Separation, Packaging, and Segregation* (corrected on site) (repeated violation)
Observation: Unwrapped or uncovered food in multiple refrigeration units.
Correction: Protect food from cross contamination by storing food in packages, covered containers, or wrappings.
|
12/31/2015 | Follow-up | |
Permit displayed. Certified food manager (CFM) present. Spoke with CFM regarding the following: 1) Written employee health policy (FDA Form 1B provided in English and Chinese) 2) Provide lid for chicken broth soup container 3) Provide multiple tongs for different meat containers in the make line unit to prevent cross contamination (employees observed using same tong for picking shrimp, vegetables, and pork)
- Hair Restraints - Effectiveness (corrected on site)
Observation: Employees observed working in the food service area without proper hair restraints.
Correction: Ensure all employees wear hair restraints such as hats, hair coverings or nets, beard restraints, and clothing that covers body hair, that are designed and worn to effectively keep their hair from contacting exposed food, clean equipment, utensils and linens, and unwrapped single-service and single-use articles. This section does not apply to food employees such as counter staff who only serve beverages and wrapped or packaged foods, hostesses, and wait staff if they present a minimal risk of contaminating exposed food
- Critical: Hands - Preventing Contamination from Hands* (corrected on site)
Observation: Employees observed scooping ready-to-eat cooked rice with a rice bowl where their fingers were touching the rice.
Correction: Provide suitable utensils such as deli tissue, spatulas, tongs, single-use gloves, or dispensing equipment to handle RTE food to prevent contamination from hands.
- Critical: Food - Packaged and Unpackaged - Separation, Packaging, and Segregation* (corrected on site)
Observation: Raw foods of animal origin stored over ready-to-eat (RTE) food in the refrigeration unit.
Correction: Separate raw foods of animal origin during storage, preparation, holding, and display from raw RTE food including foods such as fish for sushi or molluscan shellfish, or other raw RTE food such as vegetables, and cooked RTE food.
- Critical: Food - Packaged and Unpackaged - Separation, Packaging, and Segregation*
Observation: Unwrapped or uncovered food in all refrigeration units.
Correction: Protect food from cross contamination by storing food in packages, covered containers, or wrappings.
- Food Storage Containers - Identified with Common Name of Food (repeated violation)
Observation: Unlabeled food containers.
Correction: Label working containers with the common name of its contents. Consumers may be allergic to certain foods or ingredients. The mistaken use of an ingredient when the consumer has requested that it not be used may result in severe medical consequences. Liquid foods and granular foods may resemble cleaning compounds. The mistaken use of food from an unlabeled container could result in chemical poisoning.
- Utensils - In-Use - Between-Use Storage (corrected on site) (repeated violation)
Observation: In-use utensils improperly stored between use.
Correction: Store in-use utensils or dispensing utensils in one of the following manners: 1) In the food with their handles above the top of the food and the container. 2) In food that is not potentially hazardous with their handles above the top of the food within containers or equipment that can be closed. 3) On a clean portion of the food preparation table or cooking equipment only if the in-use utensil and the food-contact surface of the food preparation table or cooking equipment are cleaned and sanitized every 4 hours. 4) In running water of sufficient velocity to flush particulates to the drain. 5) In a clean, protected location if the utensils are used only with a food that is not potentially hazardous. 6) In a container of water if the water is maintained at a temperature of at least 135°F.
- Food Storage - Clean and Dry Location
Observation: Food stored on the floor or food stored less than 6" above the floor.;Elevate food storage onto approved shelving with minimum 6" legs or casters.
- Critical: Date Marking - Ready-to-Eat - Potentially Hazardous Food - Date Marking* (repeated violation)
Observation: The prepared ready-to-eat (RTE) in the refrigeration units is not properly dated for disposition.
Correction: Mark the name and "consume by" date on the container of RTE foods at the time of preparation if the food is to be held for more than 24 hours. If the food is held at 41°F or below the food shall be served or sold within 7 calendar days. Some harmful bacteria continue to grow even at refrigeration temperatures so limiting the amount of time in storage limits the amount of growth allowed for these bacteria.
- Critical: Time as a Public Health Control* (repeated violation)
Observation: No written procedures for the use of time as a public health control with potentially hazardous foods.
Correction: Provide written procedures for the use of time as a public health control. The procedures must include the following steps or practices: a. Food must be marked with the time within which it must be cooked, served or discarded. b. The food is served or discarded within four hours from the time when the food is removed from temperature control c. Food in unmarked containers or packages, or for which the time expires is discarded and d. Written procedures are maintained in the food establishment and made available to the regulatory authority upon request e. Once time is implemented as a control measure for potentially hazardous food, no other measures may be substituted.
- Critical: Time as a Public Health Control* (repeated violation)
Observation: Food for which time rather than temperature is being used as a control was not labeled or otherwise marked with a 4 hour cook, serve or discard by time.
Correction: Discard food that is not cooked and served or served if ready-to-eat within 4 hours from the point in time when the food is removed from temperature control. Clearly label or otherwise mark the food with a 4-hour cook-serve or serve by time.
- Critical: Single-Service and Single-Use, Characteristics*
Observation: Observed use of no-food grade (shopping bags) plasctic bags as food storage bags in the freezers.
Correction: Discontinue use of the non-food grade bags (shopping bags) as food contact material. Provide single-service and single-use articles that are safe and clean, and will not allow the transfer of colors, odors, or tastes to the food.
- Equipment - Fixed Equipment, Spacing or Sealing
Observation: The hand sink in the kitchen is not sealed to adjoining equipment or walls.
Correction: Seal the unit to adjoining equipment or walls since it is exposed to spillage or seepage.
- Equipment - Food Contact Surfaces, Nonfood Contact Surfaces, and Utensils
Observation: Observed accumulations of dust, dirt, food residue or other debris on the following nonfood-food contact surfaces: Bottom of food prep counters, floor of all refrigeration units, wire racks in refrigeration units, catch tray of wok station...etc.
Correction: Maintain nonfood-contact surfaces of equipment clean.
- Equipment - Cooking and Baking Equipment
Observation: The cavity of the microwave oven is observed soiled.
Correction: Using the manufacturer's recommended cleaning procedure, clean the microwave oven at least every 24 hours.
- Equipment, Utensils, Linens, and Single-Service and Single-Use Articles
Observation: Single service items observed unprotected from contamination.
Correction: Store single service items in its original protective packaging or inverted in an approved dispenser.
- Handwashing - Using a Handwashing Lavatory (corrected on site)
Observation: The handwashing facility located in the kitchen is blocked, preventing access by employees for easy handwashing.
Correction: Access to the handwashing facility identified above is to be available during all hours of operation. Remove the objects/containers preventing its use.
- Handwashing Signage/Handwashing Facilities (corrected on site)
Observation: A sign or poster that notifies food employees to wash their hands is not provided at the kitchen hand sink.
Correction: Provide a sign or poster that notifies food employees to wash their hands at all handwashing lavatories used by food employees.
- Physical Facilities - Cleaning Frequency and Restrictions
Observation: Floors, walls, and ceilings throughout the facility noted in need of cleaning.
Correction: All floors, walls, and ceilings must be cleaned as often as necessary to keep them clean. Cleaning of the physical facilities is an important measure in ensuring the protection and sanitary preparation of food. A regular cleaning schedule should be established and followed to maintain the facility in a clean and sanitary manner.
- Ventilation Systems - Cleaning Ventilation Systems - Nuisance and Discharge Prohibition
Observation: Vent filters in the hood system are not being maintained in a clean condition.
Correction: Maintain hood system vent filters in a clean condition.
|
12/21/2015 | Routine | |
Permit issued.
- Food Storage Containers - Identified with Common Name of Food
Observation: Unlabeled food containers.
Correction: Label working containers with the common name of its contents. Consumers may be allergic to certain foods or ingredients. The mistaken use of an ingredient when the consumer has requested that it not be used may result in severe medical consequences. Liquid foods and granular foods may resemble cleaning compounds. The mistaken use of food from an unlabeled container could result in chemical poisoning.
- Utensils - In-Use - Between-Use Storage (corrected on site)
Observation: In-use knives improperly stored between use.
Correction: Store in-use utensils or dispensing utensils in one of the following manners: 1) In the food with their handles above the top of the food and the container. 2) In food that is not potentially hazardous with their handles above the top of the food within containers or equipment that can be closed. 3) On a clean portion of the food preparation table or cooking equipment only if the in-use utensil and the food-contact surface of the food preparation table or cooking equipment are cleaned and sanitized every 4 hours. 4) In running water of sufficient velocity to flush particulates to the drain. 5) In a clean, protected location if the utensils are used only with a food that is not potentially hazardous. 6) In a container of water if the water is maintained at a temperature of at least 135°F.
- Critical: Date Marking - Ready-to-Eat - Potentially Hazardous Food - Date Marking* (repeated violation)
Observation: The prepared ready-to-eat (RTE) foods in the refrigeration unit is not properly dated for disposition.
Correction: Mark the name and "consume by" date on the container of RTE foods at the time of preparation if the food is to be held for more than 24 hours. If the food is held at 41°F or below the food shall be served or sold within 7 calendar days. Some harmful bacteria continue to grow even at refrigeration temperatures so limiting the amount of time in storage limits the amount of growth allowed for these bacteria.
- Critical: Time as a Public Health Control* (repeated violation)
Observation: Foods for which time rather than temperature is being used as a control was not labeled or otherwise marked with a 4 hour cook, serve or discard by time.
Correction: Discard food that is not cooked and served or served if ready-to-eat within 4 hours from the point in time when the food is removed from temperature control. Clearly label or otherwise mark the food with a 4-hour cook-serve or serve by time.
- Nonfood-Contact Surfaces - Corrosion Resistant/Nonabsorbent (repeated violation)
Observation: Observed multiple corroded prep tables and other equipment..
Correction: Nonfood contact equipment that is exposed to splash, spillage, food soiling, or requires frequent cleaning must be smooth, durable, and nonabsorbent.
|
10/21/2014 | Routine | |
- Critical: Date Marking - Ready-to-Eat - Potentially Hazardous Food - Date Marking* (corrected on site)
Observation: The prepared ready-to-eat (RTE) food in the refrigeration unit is not properly dated for disposition.
Correction: Mark the name and "consume by" date on the container of RTE foods at the time of preparation if the food is to be held for more than 24 hours. If the food is held at 41°F or below the food shall be served or sold within 7 calendar days. Some harmful bacteria continue to grow even at refrigeration temperatures so limiting the amount of time in storage limits the amount of growth allowed for these bacteria.
- Critical: Time as a Public Health Control* (corrected on site) (repeated violation)
Observation: Food for which time rather than temperature is being used as a control was not labeled or otherwise marked with a 4 hour cook, serve or discard by time.
Correction: Discard food that is not cooked and served or served if ready-to-eat within 4 hours from the point in time when the food is removed from temperature control. Clearly label or otherwise mark the food with a 4-hour cook-serve or serve by time.
- Nonfood-Contact Surfaces - Corrosion Resistant/Nonabsorbent
Observation: The nonfood contact surface of the tin foil around the hood piping, prep tables, and cardboard is not corrosion resistant, nonabsorbent, and/or smooth.
Correction: Nonfood contact equipment that is exposed to splash, spillage, food soiling, or requires frequent cleaning must be smooth, durable, and nonabsorbent.
- Equipment - Food Contact Surfaces, Nonfood Contact Surfaces, and Utensils
Observation: Observed accumulations of dust, dirt, food residue or other debris on the following nonfood-food contact surfaces: microwave and hood filters
Correction: Maintain nonfood-contact surfaces of equipment clean.
- Physical Facilities in Good Repair
Observation: Observed damaged and falling ceiling tile.
Correction: Replace the falling ceiling tile. Poor repair and maintenance compromises the functionality of the physical facilities.
|
05/30/2014 | Routine | |
permit issued
- Critical: Food - Packaged and Unpackaged - Separation, Packaging, and Segregation* (corrected on site) (repeated violation)
Observation: Raw food of animal origin holding in a manner that may cause cross contamination of to ready-to-eat food (RTE).
Correction: Separate raw foods during storage, preparation, holding, and display from raw RTE food including other raw food such as fish for sushi or molluscan shellfish, or other raw RTE food such as vegetables, and cooked RTE food.
- Critical: Food - Packaged and Unpackaged - Separation, Packaging, and Segregation* (corrected on site) (repeated violation)
Observation: Different types of raw animal foods stored in such a manner that may cause cross contamination.
Correction: Separate types of raw animal foods from each other such as beef, fish, lamb pork, and poultry during storage, preparation, holding, and display by the following: (a) Using separate equipment for each type. (b) Arranging each type of food in equipment so that cross contamination of one type with another is prevented. (c) Preparing each type of food at different times or in separate areas.
- Food Storage - Clean and Dry Location (repeated violation)
Observation: Food stored on the floor or food stored less than 6" above the floor in walk in cooler/freezer;Elevate food storage onto approved shelving with minimum 6" legs or casters.
- Critical: Time as a Public Health Control* (corrected on site)
Observation: cooked noodles, rice, and sweet sour chicken for which time rather than temperature is being used as a control was not labeled or otherwise marked with a 4 hour cook, serve or discard by time.
Correction: Discard food that is not cooked and served or served if ready-to-eat within 4 hours from the point in time when the food is removed from temperature control. Clearly label or otherwise mark the food with a 4-hour cook-serve or serve by time.
- Equipment - Food Contact Surfaces, Nonfood Contact Surfaces, and Utensils
Observation: Interior of walk in freezer needs cleaning
Correction: Clean
- Physical Facilities - Cleaning Frequency and Restrictions (repeated violation)
Observation: Floor behind roaster needs cleaning
Correction: Clean
|
10/29/2013 | Routine | |
Permit issued
- Critical: Food - Packaged and Unpackaged - Separation, Packaging, and Segregation* (repeated violation)
Observation: Raw foods of animal origin stored over ready-to-eat (RTE) food in the refrigeration unit.
Correction: Separate raw foods of animal origin during storage, preparation, holding, and display from raw RTE food including foods such as fish for sushi or molluscan shellfish, or other raw RTE food such as vegetables, and cooked RTE food.
- Food Storage - Clean and Dry Location (repeated violation)
Observation: Food stored on the floor or food stored less than 6" above the floor in walk in freezer;Elevate food storage onto approved shelving with minimum 6" legs or casters.
- Critical: Food - Potentially Hazardous Food - Cold Holding* (repeated violation)
Observation: noodles on counter cold holding at improper temperatures 61*
Correction: Relocate food to a refrigeration unit that is capable of maintaining food storage at 41°F or below.
- Critical: Food Contact Surfaces - Cleanability* (repeated violation)
Observation: The food contact surface of the card board box containing broccoli and the plastic bottle used as a rice scoop is not designed or constructed to be smooth and it contains cracks, chips, or pits that can not be easily cleaned.
Correction: Replace the box and scoop to provide a food contact surface that is smooth and easily cleanable, free of breaks, open seams, cracks, chips, pits, sharp internal angles, corners, and crevices to prevent build-up of food debris.
- Equipment - Fixed Equipment, Spacing or Sealing
Observation: The handsink seal is damaged
Correction: Seal the unit to adjoining equipment or walls since it is exposed to spillage or seepage.
|
12/13/2012 | Routine | |
Handsinks in need of cleaning. Relocate maintenance items designated area. Some corrective action taken during inspection. Health Permit renewal issued.
- Jewelry - Prohibition
Observation: Employee wearing jewelry on their arms and hands while preparing food.
Correction: Ensure employees are not wearing jewelry on their arms and hands while preparing food. This section does not apply to a plain ring such as a wedding band.
- Critical: Eating, Drinking, or Using Tobacco* (repeated violation)
Observation: In use open drinking containers stored in a manner that may contaminate food, food contact surfaces or utensils.
Correction: Employees may drink from a closed beverage container if the container is handled to prevent contamination of (1) The employee's hands (2) The container and (3) Exposed food clean equipment, utensils, and linens and unwrapped single-service and single-use articles.
- Hair Restraints - Effectiveness
Observation: Employee observed working in the food service area without proper hair restraints.
Correction: Ensure all employees wear hair restraints such as hats, hair coverings or nets, beard restraints, and clothing that covers body hair, that are designed and worn to effectively keep their hair from contacting exposed food clean equipment, utensils, and linens, and unwrapped single-service and single-use articles.
- Critical: Food - Packaged and Unpackaged - Separation, Packaging, and Segregation* (repeated violation)
Observation: Raw foods of animal origin stored over ready-to-eat (RTE) food in the refrigeration unit.
Correction: Separate raw foods of animal origin during storage, preparation, holding, and display from raw RTE food including foods such as fish for sushi or molluscan shellfish, or other raw RTE food such as vegetables, and cooked RTE food.
- Cloths - Wiping Cloths - Use Limitation
Observation: Wiping cloths improperly stored between use.
Correction: Ensure wet wiping cloths are stored in a chemical sanitizer at the proper concentration between use.
- Cloths - Wiping Cloths - Use Limitation
Observation: Improper use of wet wiping cloths under cutting boards.
Correction: Use clean wet wiping cloths for wiping spills from food-contact and nonfood-contact surfaces of equipment. Store wet wiping in a chemical sanitizer at the proper concentration between use.
- Critical: Time as a Public Health Control* (repeated violation)
Observation: Cooked chicken for which time rather than temperature is being used as a control was not labeled or otherwise marked with a 4 hour cook, serve or discard by time.
Correction: Discard food that is not cooked and served or served if ready-to-eat within 4 hours from the point in time when the food is removed from temperature control. Clearly label or otherwise mark the food with a 4-hour cook-serve or serve by time.
- Critical: Equipment and Utensils - Multiuse, Characteristics*
Observation: The food contact surfaces of the trash bags and paper menus are not safe.
Correction: Replace the EQUIPMENT to permit easy cleaning and prevent the migration of deleterious substances, or transference of colors, odors, or tastes to food.
- Equipment - Cutting Surfaces
Observation: The cutting boards are heavily scratched and scored. The food contact surface is no longer easily cleaned and sanitized due to condition.
Correction: Resurface or discard and replace the cutting boards to provide a food contact surface that is smooth, easily cleaned and sanitized.
- Critical: Equipment - Food Contact Surfaces, Nonfood Contact Surfaces, and Utensils* (repeated violation)
Observation: The following equipment food-contact surfaces were observed soiled to sight and touch: cook's thermometer, bowls and plastic tubs.
Correction: Clean and sanitize these surfaces for food contact.
- Equipment - Food Contact Surfaces, Nonfood Contact Surfaces, and Utensils (repeated violation)
Observation: Observed accumulations of dust, dirt, food residue or other debris on the following nonfood-food contact surfaces: shelving and outside of food containers.
Correction: Maintain nonfood-contact surfaces of equipment clean.
- Physical Facilities in Good Repair
Observation: Ceiling tiles are not maintained in good repair
Correction: Maintain physical facilities in good repair. Poor repair and maintenance compromises the functionality of the physical facilities.
- Physical Facilities - Cleaning Frequency and Restrictions (repeated violation)
Observation: Floors along the walls and ceiling vents noted in need of cleaning.
Correction: All floors, walls, and ceilings must be cleaned as often as necessary to keep them clean. Cleaning of the physical facilities is an important measure in ensuring the protection and sanitary preparation of food. A regular cleaning schedule should be established and followed to maintain the facility in a clean and sanitary manner.
- Ventilation Systems - Cleaning Ventilation Systems - Nuisance and Discharge Prohibition (repeated violation)
Observation: Vent filters in the hood system are not being maintained in a clean condition.
Correction: Maintain hood system vent filters in a clean condition.
- Toxics - Separation of Toxics (repeated violation)
Observation: Containers of wood stain, etc are not properly stored to prevent the contamination of food, equipment, utensils, linens or single service items.
Correction: Containers of HAZARDOUS PRODUCT must be separated by spacing or partitioning to prevent contamination of food, equipment, utensils, linens or single service items.
|
02/21/2012 | Routine | |
Restaurant representatives - add corrected or new information about China #1 Chinese Restaurant, 517 Kempsville Rd. 101, Chesapeake, VA 23320 »