- Critical: Food Contact Surfaces Sanitized or Warewashing Sanitization (corrected on site)
- Details:
- The dishwasher is not dispensing any sanitizer. The machine was run 3 times. The sanitizer level is less than 10ppm Cl. Repair the dishwasher to dispense sanitizer at a minimum of 50ppm. Correct today. Until the dishwasher is operating properly, warewashing must occur in the 3-comp sink using the wash-rinse-sanitize-air dry system. Informational sticker provided.
- Comment:
- All food contact surfaces of utensils and equipment shall be clean and sanitized. (113984(e), 114097, 114099.1, 114099.4, 114099.6, 114101 (b-d), 114105, 114109, 114111, 114113, 114115 (a, b, d), 114117, 114125(b), 114135, 114141)
- Hot and Cold Holding Temperatures
- Details:
- The walk-in cooler is 47-48F (food inside walk-in is 44-45F), the 2 door prep unit is 45F and the liquid egg is 49F. Maintain cold food at 41F or below. Correct today.
- Comment:
- Potentially hazardous foods shall be held at or below 41/ 45°F or at or above 135°F. (113996, 113998, 114037, 114343(a))
- Approved / Sufficient Ventilation and Lighting
- Details:
- One of the light covers at the hood is hanging/loose. Replace light cover by 2 weeks.
- Comment:
- Exhaust hoods shall be provided to remove toxic gases, heat, grease, vapors and smoke and be approved by the local building department. Canopy-type hoods shall extend 6" beyond all cooking equipment. All areas shall have sufficient ventilation to facilitate proper food storage. Toilet rooms shall be vented to the outside air by a screened openable window, an air shaft, or a light-switch activated exhaust fan, consistent with local building codes. (114149, 114149.1) Adequate lighting shall be provided in all areas to facilitate cleaning and inspection. Light fixtures in areas where open food is stored, served, prepared, and where utensils are washed shall be of shatterproof construction or protected with light shields. (114149.2, 114149.3, 114252, 114252.1)
- Proper Use and Storage of Wiping Cloths
- Details:
- Observed multiple wet cloths on the counters in the kitchen. Store wiping cloths in a bucket with a sanitizing solution in between uses. Correct today.
- Comment:
- Wiping cloths used to wipe service counters, scales or other surfaces that may come into contact with food shall be used only once unless kept in clean water with sanitizer. (114135, 114185.1 114185.3 (d-e))
- Floors, Walls, Ceilings
- Details:
- Clean and Maintained
- Comment:
- The floors behind and under equipment have food and non-food debris. Clean floors by 2 weeks.
|
02/08/2016 | Routine |
- Demonstration of knowledge
- Comment:
- All food employees shall have adequate knowledge of and be trained in food safety as it relates to their assigned duties. (113947) Food facilities that prepare, handle or serve non-prepackaged potentially hazardous food, shall have an employee who has passed an approved food safety certification examination. (113947-113947.1) Any food handler hired after June 1, 2011 shall obtain a Food Handler Card within 30 days (113948).
- Hot and Cold Holding Temperatures (corrected on site)
- Comment:
- Potentially hazardous foods shall be held at or below 41/ 45°F or at or above 135°F. (113996, 113998, 114037, 114343(a))
- Food Contact Surfaces Sanitized or Warewashing Sanitization
- Comment:
- All food contact surfaces of utensils and equipment shall be clean and sanitized. (113984(e), 114097, 114099.1, 114099.4, 114099.6, 114101 (b-d), 114105, 114109, 114111, 114113, 114115 (a, b, d), 114117, 114125(b), 114135, 114141)
- Equipment/Utensils Approved and in Good Repair
- Comment:
- All utensils and equipment shall be fully operative and in good repair. (114175). All utensils and equipment shall be approved, installed properly, and meet applicable standards. (114130, 114130.1, 114130.2, 114130.3, 114130.4, 114130.5, 114132, 114133, 114137, 114139, 114153, 114155, 114163, 114165, 114167, 114169, 114177, 114180, 114182)
- Equipment/Utensils/Linens: Proper Storage / Use (corrected on site)
- Comment:
- All clean and soiled linen shall be properly stored non-food items shall be stored and displayed separate from food and food-contact surfaces. (114185.3 - 114185.4) Utensils and equipment shall be handled and stored so as to be protected from contamination. (114074 - 114075, 114081, 114119, 114121, 114161, 114178, 114179, 114083, 114185, 114185.2, 114185.5)
- Plumbing Maintained
- Details:
- Approved Back Flow Device
|
12/01/2014 | Routine |
| No violation noted during this evaluation. | 12/18/2013 | Reinspection |
- Improper Hot and Cold Holding Temperatures
- Comment:
- Potentially hazardous foods shall be held at or below 41/ 45°F or at or above 135°F. (113996, 113998, 114037, 114343(a))
- Food Contact Surfaces Not Cleaned and Sanitized
- Comment:
- All food contact surfaces of utensils and equipment shall be clean and sanitized. (113984(e), 114097, 114099.1, 114099.4, 114099.6, 114101 (b-d), 114105, 114109, 114111, 114113, 114115 (a, b, d), 114117, 114125(b), 114135, 114141)
- Food Unprotected from Contamination During Storage
- Comment:
- All food shall be separated and protected from contamination. (113984 (a, b, c, d, f), 113986, 114060, 114067(a, d, e, j), 114069(a, b), 114077, 114089.1 (c), 114143 (c))
- Toxic Substances Improperly Identified/Stored/Used
- Comment:
- All poisonous substances, detergents, bleaches, and cleaning compounds shall be stored separate from food, utensils, packing material and food-contact surfaces. (114254, 114254.1, 114254.2)
- Nonfood Contact Surfaces Not Clean
- Comment:
- All nonfood contact surfaces of utensils and equipment shall be clean. (114115 (c))
- Warewashing Facilites Not Properly Maintained
- Comment:
- Food facilities that prepare food shall be equipped with warewashing facilities. Testing equipment and materials shall be provided to measure the applicable sanitization method. (114067(f,g), 114099, 114099.3, 114099.5, 114101(a), 114101.1, 114101.2, 114103, 114107, 114125)
- Equipment/Utensils Not Approved/Installed/Cleaned
- Comment:
- All utensils and equipment shall be fully operative and in good repair. (114175). All utensils and equipment shall be approved, installed properly, and meet applicable standards. (114130, 114130.1, 114130.2, 114130.3, 114130.4, 114130.5, 114132, 114133, 114137, 114139, 114153, 114155, 114163, 114165, 114167, 114169, 114177, 114180, 114182)
- Unapproved / Insufficient Ventilation and Lighting
- Comment:
- Exhaust hoods shall be provided to remove toxic gases, heat, grease, vapors and smoke and be approved by the local building department. Canopy-type hoods shall extend 6" beyond all cooking equipment. All areas shall have sufficient ventilation to facilitate proper food storage. Toilet rooms shall be vented to the outside air by a screened openable window, an air shaft, or a light-switch activated exhaust fan, consistent with local building codes. (114149, 114149.1) Adequate lighting shall be provided in all areas to facilitate cleaning and inspection. Light fixtures in areas where open food is stored, served, prepared, and where utensils are washed shall be of shatterproof construction or protected with light shields. (114149.2, 114149.3, 114252, 114252.1)
- Floors, Walls, Ceilings
- Details:
- Not Clean and Maintained
- Signs Not Posted
- Details:
- Last Inspection Rpt Unavailable
|
12/05/2013 | Routine |
| No violation noted during this evaluation. | 12/14/2012 | Reinspection |
- Critical: Food Contact Surfaces Not Cleaned and Sanitized
- Comment:
- All food contact surfaces of utensils and equipment shall be clean and sanitized. (113984(e), 114097, 114099.1, 114099.4, 114099.6, 114101 (b-d), 114105, 114109, 114111, 114113, 114115 (a, b, d), 114117, 114125(b), 114135, 114141)
- Improper Hot and Cold Holding Temperatures
- Comment:
- Potentially hazardous foods shall be held at or below 41/ 45°F or at or above 135°F. (113996, 113998, 114037, 114343(a))
- Food Unprotected from Contamination During Storage
- Comment:
- All food shall be separated and protected from contamination. (113984 (a, b, c, d, f), 113986, 114060, 114067(a, d, e, j), 114069(a, b), 114077, 114089.1 (c), 114143 (c))
- Nonfood Contact Surfaces Not Clean
- Comment:
- All nonfood contact surfaces of utensils and equipment shall be clean. (114115 (c))
- Equipment/Utensils Not Approved/Installed/Cleaned
- Comment:
- All utensils and equipment shall be fully operative and in good repair. (114175). All utensils and equipment shall be approved, installed properly, and meet applicable standards. (114130, 114130.1, 114130.2, 114130.3, 114130.4, 114130.5, 114132, 114133, 114137, 114139, 114153, 114155, 114163, 114165, 114167, 114169, 114177, 114180, 114182)
- Improper Use and Storage of Wiping Cloths
- Comment:
- Wiping cloths used to wipe service counters, scales or other surfaces that may come into contact with food shall be used only once unless kept in clean water with sanitizer. (114135, 114185.1 114185.3 (d-e))
- Floors, Walls, Ceilings
- Details:
- Not Clean and Maintained
|
10/19/2012 | Routine |
Restaurant representatives - add corrected or new information about Chubbys Diner, 737 N Main St, Manteca, CA 95336 »