- Critical: Demonstration of Knowledge* (corrected on site) (repeated violation)
Observation: The person in charge failed to state the required temperatures and holding times for the following conditions of potentially hazardous food: (1) Refrigerated storage, (2) Hot holding, (3) Cooling, and (4) Reheating.
Correction: Ensure the designated person in charge (PIC) is knowledgeable about foodborne disease prevention, Hazardous Analysis Critical Control Point principles and Regulation requirements. The PIC should be prepared to recognize conditions that may contribute to foodborne illness. The PIC must also recognize conditions that fail to comply with Regulation requirements and be authorized to take the appropriate preventive and corrective actions to ensure that the Regulations' objectives are fulfilled.
- Critical: Date Marking - Ready-to-Eat - Potentially Hazardous Food - Date Marking* (corrected on site) (repeated violation)
Observation: The prepared ready-to-eat shrimp sauce in the refrigeration unit is not properly dated for disposition.
Correction: Mark the name and "consume by" date on the container of RTE foods at the time of preparation if the food is to be held for more than 24 hours. If the food is held at 41°F or below the food shall be served or sold within 7 calendar days. Some harmful bacteria continue to grow even at refrigeration temperatures so limiting the amount of time in storage limits the amount of growth allowed for these bacteria.
- Nonfood-Contact Surfaces - Corrosion Resistant/Nonabsorbent (repeated violation)
Observation: The nonfood contact surface of the shelves inside the walk-in refrigerator is not corrosion resistant, nonabsorbent, and/or smooth.
Correction: Nonfood contact equipment that is exposed to splash, spillage, food soiling, or requires frequent cleaning must be smooth, durable, and nonabsorbent.
- Sanitizing Solutions, Testing Devices (repeated violation)
Observation: There is no properly working test kit provided in the facility for monitoring the concentration of the chemical sanitizing solutions.
Correction: Obtain a chlorine test kit so that employees can accurately monitor the concentration of the sanitizing solutions and maintain them at a safe and effective level.
- Critical: Equipment - Food Contact Surfaces and Utensils (corrected on site)
Observation: The temperature measuring device probe was not observed cleaned before use and/or storage.
Correction: Clean food contact surfaces of equipment and utensils between and after uses to prevent cross contamination.
- Physical Facilities in Good Repair (repeated violation)
Observation: Wall behind the mop sink is not maintained in good repair.
Correction: Maintain physical facilities in good repair. Poor repair and maintenance compromises the functionality of the physical facilities.
- Premises - Maintaining Premises - Unnecessary Items and Litter (repeated violation)
Observation: Facility is storing unnecessary items to the operation or maintenance of the establishment.
Correction: Remove all unnecessary items from the facility. The presence of unnecessary articles, including equipment which is no longer used, makes regular and effective cleaning more difficult and less likely. It can also provide harborage for insects and rodents.
|
11/18/2015 | Routine | |
| No violation noted during this evaluation. | 07/10/2015 | Follow-up | |
- Critical: Person in Charge - Assignment of Responsibility*
Observation: The person in charge was not available at the time of inspection.
Correction: The permit holder shall designate a person in charge who is authorized to monitor and manage all food establishment operations and who is authorized to take actions to ensure that the Regulations' objectives are fulfilled.
- Critical: Demonstration of Knowledge* (repeated violation)
Observation: The person in charge failed to state the required temperatures and holding times for the following conditions of potentially hazardous food: (1) Refrigerated storage, (2) Hot holding, (3) Cooling, and (4) Reheating.
Correction: Ensure the designated person in charge (PIC) is knowledgeable about foodborne disease prevention, Hazardous Analysis Critical Control Point principles and Regulation requirements. The PIC should be prepared to recognize conditions that may contribute to foodborne illness. The PIC must also recognize conditions that fail to comply with Regulation requirements and be authorized to take the appropriate preventive and corrective actions to ensure that the Regulations' objectives are fulfilled.
- Critical: Demonstration of Knowledge* (repeated violation)
Observation: The person in charge failed to state the minimum cook temperatures and times for potentially hazardous food.
Correction: Ensure the designated person in charge (PIC) is knowledgeable about foodborne disease prevention, Hazardous Analysis Critical Control Point principles and Regulation requirements. The PIC should be prepared to recognize conditions that may contribute to foodborne illness. The PIC must also recognize conditions that fail to comply with Regulation requirements and be authorized to take the appropriate preventive and corrective actions to ensure that the Regulations' objectives are fulfilled.
- Critical: Demonstration of Knowledge* (repeated violation)
Observation: The person in charge failed to explain the correct procedures for cleaning and sanitizing utensils and food-contact surfaces of equipment.
Correction: Ensure the designated person in charge (PIC) is knowledgeable about foodborne disease prevention, Hazardous Analysis Critical Control Point principles and Regulation requirements. The PIC should be prepared to recognize conditions that may contribute to foodborne illness. The PIC must also recognize conditions that fail to comply with Regulation requirements and be authorized to take the appropriate preventive and corrective actions to ensure that the Regulations' objectives are fulfilled.
- Person in Charge
Observation: Food employees are not informed of their responsibility to report to their PIC information concerning their health and activities as they relate to diseases transmitted through food.
Correction: PIC is to advise employees of their responsibility to report in accordance with law information concerning their health and activities as they relate to diseases transmitted through food.
- Critical: Food - Packaged and Unpackaged - Separation, Packaging, and Segregation*
Observation: Different types of raw animal foods stored in such a manner that may cause cross contamination.
Correction: Separate types of raw animal foods from each other such as beef, fish, lamb pork, and poultry during storage, preparation, holding, and display by the following: (a) Using separate equipment for each type. (b) Arranging each type of food in equipment so that cross contamination of one type with another is prevented. (c) Preparing each type of food at different times or in separate areas.
- Utensils - In-Use - Between-Use Storage (repeated violation)
Observation: In-use utensils improperly stored between use. Rice scoop.
Correction: Store in-use utensils or dispensing utensils in one of the following manners: 1) In the food with their handles above the top of the food and the container. 2) In food that is not potentially hazardous with their handles above the top of the food within containers or equipment that can be closed. 3) On a clean portion of the food preparation table or cooking equipment only if the in-use utensil and the food-contact surface of the food preparation table or cooking equipment are cleaned and sanitized every 4 hours. 4) In running water of sufficient velocity to flush particulates to the drain. 5) In a clean, protected location if the utensils are used only with a food that is not potentially hazardous. 6) In a container of water if the water is maintained at a temperature of at least 135°F.
- Cloths - Wiping Cloths - Use Limitation (repeated violation)
Observation: Improper use of wet wiping cloths.
Correction: Use clean wet wiping cloths for wiping spills from food-contact and nonfood-contact surfaces of equipment. Store wet wiping in a chemical sanitizer at the proper concentration between use.
- Food Storage - Clean and Dry Location
Observation: Food stored on the floor or food stored less than 6" above the floor. Cooked carrots.;Elevate food storage onto approved shelving with minimum 6" legs or casters.
- Critical: Date Marking - Ready-to-Eat - Potentially Hazardous Food - Date Marking* (repeated violation)
Observation: The prepared ready-to-eat (RTE) shrimp sauce in the refrigeration unit is not properly dated for disposition.
Correction: Mark the name and "consume by" date on the container of RTE foods at the time of preparation if the food is to be held for more than 24 hours. If the food is held at 41°F or below the food shall be served or sold within 7 calendar days. Some harmful bacteria continue to grow even at refrigeration temperatures so limiting the amount of time in storage limits the amount of growth allowed for these bacteria.
- Nonfood-Contact Surfaces - Corrosion Resistant/Nonabsorbent
Observation: The nonfood contact surface of the shelves in the walk-in refrigerator are not corrosion resistant, nonabsorbent, and/or smooth.
Correction: Nonfood contact equipment that is exposed to splash, spillage, food soiling, or requires frequent cleaning must be smooth, durable, and nonabsorbent.
- Sanitizing Solutions, Testing Devices
Observation: There is no properly working test kit provided in the facility for monitoring the concentration of the chemical sanitizing solutions.
Correction: Obtain a chlorine test kit so that employees can accurately monitor the concentration of the sanitizing solutions and maintain them at a safe and effective level.
- Single-Service and Single-Use Articles, Use Limitation
Observation: Manufacturer milk containers were observed reused for the storage of tea.
Correction: Discontinue the reuse of manufacturer milk containers for tea storage. Provide approved reusable food storage containers designed for your food storage needs.
- Critical: Equipment - Food Contact Surfaces, Nonfood Contact Surfaces, and Utensils* (corrected on site) (repeated violation)
Observation: The following utensils were observed soiled to sight and touch: Knives.
Correction: Clean and sanitize these surfaces for food contact.
- Outer Openings - Protected
Observation: Outer opening of the food establishment is not protected against entry of insects and rodents.
Correction: Protect the food establishment against the entry of insects and rodents by 1. Filling or closing holes and other gaps along floors, walls, and ceilings, 2. Closed, tight fitting windows, and 3. Solid, self-closing, tight-fitting doors. Insects and rodents are vectors of disease-causing microorganisms which may be transmitted to humans by contamination of food and food-contact surfaces.
- Physical Facilities in Good Repair (repeated violation)
Observation: Walls in the utility room and bathroom is not maintained in good repair.
Correction: Maintain physical facilities in good repair. Poor repair and maintenance compromises the functionality of the physical facilities.
- Physical Facilities - Cleaning Frequency and Restrictions (repeated violation)
Observation: Floors and walls in the kitchen noted in need of cleaning.
Correction: All floors, walls, and ceilings must be cleaned as often as necessary to keep them clean. Cleaning of the physical facilities is an important measure in ensuring the protection and sanitary preparation of food. A regular cleaning schedule should be established and followed to maintain the facility in a clean and sanitary manner.
- Premises - Maintaining Premises - Unnecessary Items and Litter (repeated violation)
Observation: Facility is storing unnecessary items to the operation or maintenance of the establishment.
Correction: Remove all unnecessary items from the facility. The presence of unnecessary articles, including equipment which is no longer used, makes regular and effective cleaning more difficult and less likely. It can also provide harborage for insects and rodents.
|
07/09/2015 | Routine | |
- Critical: Demonstration of Knowledge* (corrected on site)
Observation: The person in charge failed to state the required temperatures and holding times for the following conditions of potentially hazardous food: (1) Refrigerated storage, (2) Hot holding, (3) Cooling, and (4) Reheating.
Correction: Ensure the designated person in charge (PIC) is knowledgeable about foodborne disease prevention, Hazardous Analysis Critical Control Point principles and Regulation requirements. The PIC should be prepared to recognize conditions that may contribute to foodborne illness. The PIC must also recognize conditions that fail to comply with Regulation requirements and be authorized to take the appropriate preventive and corrective actions to ensure that the Regulations' objectives are fulfilled.
- Critical: Demonstration of Knowledge* (corrected on site)
Observation: The person in charge failed to explain the relationship between food safety and providing equipment that is: (a) Sufficient in number and capacity, and (b) Properly designed, constructed, located, installed, operated, and cleaned.
Correction: Ensure the designated person in charge (PIC) is knowledgeable about foodborne disease prevention, Hazardous Analysis Critical Control Point principles and Regulation requirements. The PIC should be prepared to recognize conditions that may contribute to foodborne illness. The PIC must also recognize conditions that fail to comply with Regulation requirements and be authorized to take the appropriate preventive and corrective actions to ensure that the Regulations' objectives are fulfilled.
- Food - Packaged and Unpackaged - Separation, Packaging, and Segregation (corrected on site)
Observation: Observed that cut vegetables was not protected from contamination because it was not in packages, covered containers, or wrapped.
Correction: Prevent cross-contamination by storing food in packages, covered containers, or wrappings.
- Ice Used as Exterior Coolant - Prohibited as Ingredient (corrected on site)
Observation: Ice used as a medium for cooling the exterior surfaces of food is also for drink ice or used as food.
Correction: Cease use of ice used as a cooling medium for food. Ice that has been in contact with unsanitized surfaces or raw animal foods may contain pathogens and other contaminants.
- Utensils - In-Use - Between-Use Storage (corrected on site) (repeated violation)
Observation: Dispensing utensils improperly stored between uses. Ice scoop stored on towel and rice scoop stored in room temperature water.
Correction: Store in-use utensils or dispensing utensils in one of the following manners: 1) In the food with their handles above the top of the food and the container. 2) In food that is not potentially hazardous with their handles above the top of the food within containers or equipment that can be closed. 3) On a clean portion of the food preparation table or cooking equipment only if the in-use utensil and the food-contact surface of the food preparation table or cooking equipment are cleaned and sanitized every 4 hours. 4) In running water of sufficient velocity to flush particulates to the drain. 5) In a clean, protected location if the utensils are used only with a food that is not potentially hazardous. 6) In a container of water if the water is maintained at a temperature of at least 135°F.
- Critical: Date Marking - Ready-to-Eat - Potentially Hazardous Food - Date Marking* (corrected on site) (repeated violation)
Observation: The prepared ready-to-eat (RTE) shrimp sauce in the refrigeration unit is not properly dated for disposition.
Correction: Mark the name and "consume by" date on the container of RTE foods at the time of preparation if the food is to be held for more than 24 hours. If the food is held at 41°F or below the food shall be served or sold within 7 calendar days. Some harmful bacteria continue to grow even at refrigeration temperatures so limiting the amount of time in storage limits the amount of growth allowed for these bacteria.
- Hand Drying Provision (corrected on site) (repeated violation)
Observation: No disposable towels were provided at the hand washing lavatory in the kitchen.
Correction: Hand drying devices such as individual disposable paper towels, a continuous towel system that supplies the user with a clean towel or heated air hand drying device must be provided at all hand washing lavatories to encourage proper hand washing and avoid employees to drying their hands on their clothing or other unclean materials
- Physical Facilities in Good Repair (repeated violation)
Observation: Walls in the employee rest-room and at the kitchen handwashing sink is not maintained in good repair. Paint peeling and dry wall damaged.
Correction: Maintain physical facilities in good repair. Poor repair and maintenance compromises the functionality of the physical facilities.
- Physical Facilities - Cleaning Frequency and Restrictions (repeated violation)
Observation: Floors and walls in the kitchen noted in need of cleaning.
Correction: All floors, walls, and ceilings must be cleaned as often as necessary to keep them clean. Cleaning of the physical facilities is an important measure in ensuring the protection and sanitary preparation of food. A regular cleaning schedule should be established and followed to maintain the facility in a clean and sanitary manner.
- Premises - Maintaining Premises - Unnecessary Items and Litter (repeated violation)
Observation: Facility is storing unnecessary items to the operation or maintenance of the establishment.
Correction: Remove all unnecessary items from the facility. The presence of unnecessary articles, including equipment which is no longer used, makes regular and effective cleaning more difficult and less likely. It can also provide harborage for insects and rodents.
- Toxics - Presence and Use Restriction (corrected on site)
Observation: Unnecessary poisonous or toxic materials found in the food establishment. Weed killer.
Correction: Remove unnecessary poisonous or toxic materials.
|
03/09/2015 | Routine | |
- Critical: Demonstration of Knowledge* (corrected on site)
Observation: The person in charge failed to explain the correct procedures for cleaning and sanitizing utensils and food-contact surfaces of equipment.
Correction: Ensure the designated person in charge (PIC) is knowledgeable about foodborne disease prevention, Hazardous Analysis Critical Control Point principles and Regulation requirements. The PIC should be prepared to recognize conditions that may contribute to foodborne illness. The PIC must also recognize conditions that fail to comply with Regulation requirements and be authorized to take the appropriate preventive and corrective actions to ensure that the Regulations' objectives are fulfilled.
- Critical: Demonstration of Knowledge* (corrected on site)
Observation: The person in charge failed to explain his or her responsibility in preventing the transmission of foodborne disease by an employee who has a disease or a medical condition that may cause foodborne disease.
Correction: Ensure the designated person in charge (PIC) is knowledgeable about foodborne disease prevention, Hazardous Analysis Critical Control Point principles and Regulation requirements. The PIC should be prepared to recognize conditions that may contribute to foodborne illness. The PIC must also recognize conditions that fail to comply with Regulation requirements and be authorized to take the appropriate preventive and corrective actions to ensure that the Regulations' objectives are fulfilled.
- Critical: Food Contact with Equipment and Utensils* (corrected on site)
Observation: Food in contact with equipment or utensils that have not been cleaned or sanitized as required. Knife used to cut raw beef.
Correction: Use only cleaned and sanitized utensils or equipment during food preparation.
- Cloths - Wiping Cloths - Use Limitation (repeated violation)
Observation: There are no wiping cloths used.
Correction: Use clean wet wiping cloths for wiping spills from food-contact and nonfood-contact surfaces of equipment. Store wet wiping in a chemical sanitizer at the proper concentration between use.
- Thawing (corrected on site)
Observation: Improper methods used to thaw shrimp.
Correction: Thaw potentially hazardous foods by either of the following methods: 1. Under refrigeration that maintains food temperature at 41°F (45°F) 2. Completely submerged under running water at a temperature of 70°F or below with sufficient water velocity to agitate and float off loose particles in an overflow. Ready-to-eat food shall not exceed 41°F and raw animal foods shall not exceed 41°F for more than four hours 3. As part of the cooking process
- Critical: Date Marking - Ready-to-Eat - Potentially Hazardous Food - Date Marking* (corrected on site) (repeated violation)
Observation: The prepared shrimp sauce in the refrigeration unit is not properly dated for disposition.
Correction: Mark the name and "consume by" date on the container of RTE foods at the time of preparation if the food is to be held for more than 24 hours. If the food is held at 41°F or below the food shall be served or sold within 7 calendar days. Some harmful bacteria continue to grow even at refrigeration temperatures so limiting the amount of time in storage limits the amount of growth allowed for these bacteria.
- Critical: Equipment - Food Contact Surfaces, Nonfood Contact Surfaces, and Utensils* (corrected on site)
Observation: The following utensils were observed soiled to sight and touch: Dispensing utensils.
Correction: Clean and sanitize these surfaces for food contact.
- Non-Food Contact Surfaces
Observation: The nonfood contact surface of the preparation tables and dishwashing machine has accumulations of grime and debris.
Correction: Clean the surface at a frequency necessary to preclude accumulation of soil residues that become encrusted or attract insects and rodents.
- Critical: Equipment and Utensils - Before Use After Cleaning* (corrected on site) (repeated violation)
Observation: The food-contact surfaces of the following equipment were not observed sanitized: Dishes through dishmachine and knife used to prepare raw product.
Correction: After cleaning and rinsing of the food-contact surface, the surface shall be effectively sanitized before coming in contact with food and before use.
- Plumbing System Maintained in Good Repair
Observation: Plumbing connections under the hand sink are leaking.
Correction: Plumbing systems and components shall be maintained in good repair.
- Physical Facilities in Good Repair
Observation: Walls in mop sink room are not maintained in good repair.
Correction: Maintain physical facilities in good repair. Poor repair and maintenance compromises the functionality of the physical facilities.
- Physical Facilities - Cleaning Frequency and Restrictions
Observation: Floors, walls, and ceilings in the kitchen noted in need of cleaning.
Correction: All floors, walls, and ceilings must be cleaned as often as necessary to keep them clean. Cleaning of the physical facilities is an important measure in ensuring the protection and sanitary preparation of food. A regular cleaning schedule should be established and followed to maintain the facility in a clean and sanitary manner.
- Premises - Maintaining Premises - Unnecessary Items and Litter (repeated violation)
Observation: Facility is storing unnecessary items to the operation or maintenance of the establishment.
Correction: Remove all unnecessary items from the facility. The presence of unnecessary articles, including equipment which is no longer used, makes regular and effective cleaning more difficult and less likely. It can also provide harborage for insects and rodents.
- Critical: Toxics - Conditions of Use* (corrected on site)
Observation: Pesticides are not being applied by a certified applicator.
Correction: Restricted used pesticides are to be applied by an applicator certified as defined in 7 USC 136(e) Certified Applicator, of the Federal Insecticide, Rodenticide Act, or a person under the direct supervision of a certified applicator.
|
03/05/2014 | Routine | |
- Critical: Hands and Arms - Clean condition* (corrected on site)
Observation: Food employees observed with soiled hands and arms.
Correction: Inform all food employees to keep their hands and exposed portions of their arms clean.
- Critical: Food - Packaged and Unpackaged - Separation, Packaging, and Segregation* (corrected on site) (repeated violation)
Observation: Different types of raw animal foods stored in such a manner that may cause cross contamination.
Correction: Separate types of raw animal foods from each other such as beef, fish, lamb pork, and poultry during storage, preparation, holding, and display by the following: (a) Using separate equipment for each type. (b) Arranging each type of food in equipment so that cross contamination of one type with another is prevented. (c) Preparing each type of food at different times or in separate areas.
- Utensils - In-Use - Between-Use Storage
Observation: In-use utensils improperly stored between use.
Correction: Store in-use utensils or dispensing utensils in one of the following manners: 1) In the food with their handles above the top of the food and the container. 2) In food that is not potentially hazardous with their handles above the top of the food within containers or equipment that can be closed. 3) On a clean portion of the food preparation table or cooking equipment only if the in-use utensil and the food-contact surface of the food preparation table or cooking equipment are cleaned and sanitized every 4 hours. 4) In running water of sufficient velocity to flush particulates to the drain. 5) In a clean, protected location if the utensils are used only with a food that is not potentially hazardous. 6) In a container of water if the water is maintained at a temperature of at least 135°F.
- Cloths - Wiping Cloths - Use Limitation
Observation: Heavily soiled wiping cloths in use.
Correction: Replace wiping cloths once visibly soiled. Wiping cloths shall be free of food debris and visible soil. Facility has only two wiping cloths, both visibly soiled.
- Cloths - Wiping Cloths - Use Limitation
Observation: Wiping cloths improperly stored between use.
Correction: Ensure wet wiping cloths are stored in a chemical sanitizer at the proper concentration between use.
- Critical: Date Marking - Ready-to-Eat - Potentially Hazardous Food - Date Marking* (corrected on site) (repeated violation)
Observation: The prepared ready-to-eat (RTE) shrimp sauce in the refrigeration unit is not properly dated for disposition.
Correction: Mark the name and "consume by" date on the container of RTE foods at the time of preparation if the food is to be held for more than 24 hours. If the food is held at 41°F or below the food shall be served or sold within 7 calendar days. Some harmful bacteria continue to grow even at refrigeration temperatures so limiting the amount of time in storage limits the amount of growth allowed for these bacteria.
- Sanitizing Solutions, Testing Devices (repeated violation)
Observation: There is no properly working test kit provided in the facility for monitoring the concentration of the chemical sanitizing solutions.
Correction: Obtain a chlorine test kit so that employees can accurately monitor the concentration of the sanitizing solutions and maintain them at a safe and effective level.
- Equipment and Utensils - Good Repair and Calibration
Observation: Chest freezer lid was observed in a state of repair and condition preventing effective maintenance and easy cleaning.
Correction: Discard, replace or repair the freezer lid to provide proper operation, accuracy, functioning, maintenance, and cleanability per Part IV, Article 1 and 2 of this chapter.
- Critical: Equipment and Utensils - Before Use After Cleaning* (corrected on site) (repeated violation)
Observation: The food-contact surfaces of the following equipment were not observed sanitized: Cutting boards washed and placed back onto the preparation table.
Correction: After cleaning and rinsing of the food-contact surface, the surface shall be effectively sanitized before coming in contact with food and before use.
- Hand Drying Provision (repeated violation)
Observation: No disposable towels were provided at the hand washing lavatory in the kitchen.
Correction: Hand drying devices such as individual disposable paper towels, a continuous towel system that supplies the user with a clean towel or heated air hand drying device must be provided at all hand washing lavatories to encourage proper hand washing and avoid employees to drying their hands on their clothing or other unclean materials
- Premises - Maintaining Premises - Unnecessary Items and Litter
Observation: Facility is storing unnecessary items to the operation or maintenance of the establishment in the dry storage area.
Correction: Remove all unnecessary items from the facility. The presence of unnecessary articles, including equipment which is no longer used, makes regular and effective cleaning more difficult and less likely. It can also provide harborage for insects and rodents.
|
02/15/2013 | Routine | |
Restaurant representatives - add corrected or new information about Tokyo Japanese Steak House, 28 Commonwealth Ave., Bristol, VA 24201 »