- Critical: Manual and Mechanical Warewash
- Comment:
- Corrected by providing 300ppm Quat sanitizer
- General violation description:
- 4-501.114 - A chemical SANITIZER used in a SANITIZING solution for a manual or mechanical operation at exposure times specified under 4-703.11(C) shall be listed in 21 CFR 178.1010 Sanitizing solutions, shall be used in accordance with the EPA-approved manufacturer's label use instructions, and shall be used as follows: (A) A chlorine solution shall have a minimum temperature based on the concentration and pH of the solution as listed in the following chart
- Critical: Potentially Hazardous Food (Ti
- Comment:
- Corrected by holding phf at 41F.
- General violation description:
- 3-501.16 - Except during preparation, cooking, or cooling, or when time is used as the public health control as specified under 3-501.19, POTENTIALLY HAZARDOUS FOOD shall be maintained: (A) At 60C (140F) or above, except that roasts cooked to a temperature and for a time specified under 3-401.11(B) or reheated as specified in 3-403.11(E) may be held at a temperature of 54C (1300F)
|
10/14/2014 | Follow-up |
- Critical: Manual and Mechanical Warewash
- Items:
- Quaternary ammonia solution
- Locations:
- 3 Compartment sink sanitizing compartment
- Comment:
- Quat sanitizer was below 150 ppm. Provide 150-400 ppm as required by sanitizer manufacturer. The sanitizer was changed to provide 150 ppm. A follow up will be conducted.,
- General violation description:
- 4-501.114 - A chemical SANITIZER used in a SANITIZING solution for a manual or mechanical operation at exposure times specified under 4-703.11(C) shall be listed in 21 CFR 178.1010 Sanitizing solutions, shall be used in accordance with the EPA-approved manufacturer's label use instructions, and shall be used as follows: (A) A chlorine solution shall have a minimum temperature based on the concentration and pH of the solution as listed in the following chart
- Critical: Potentially Hazardous Food (Ti
- Items:
- Cold food item(s)
- Problems:
- Stored above 41 degrees f
- Corrections:
- Store below 41 degrees F.
- Comment:
- In the sandwich make table: teriyaki chicken was at 53f in pre-portioned paper trays. The layer below was 45f. Other chicken was at 44f. Roast beef was at 49f. Provolone cheese 44f, cut lettuce 44f. Repeat violation: Hold at or below 41f. Fax completed risk control plan to number on form within 2 days. Correct violation today. Do not use cooler past today unless 41f food temp or lower can be maintained. A follow up will be conducted.,
- General violation description:
- 3-501.16 - Except during preparation, cooking, or cooling, or when time is used as the public health control as specified under 3-501.19, POTENTIALLY HAZARDOUS FOOD shall be maintained: (A) At 60C (140F) or above, except that roasts cooked to a temperature and for a time specified under 3-401.11(B) or reheated as specified in 3-403.11(E) may be held at a temperature of 54C (1300F)
|
09/23/2014 | Routine |
- Critical: Potentially Hazardous Food (Ti
- Comment:
- CORRECTED BY HOLDING PHF AT 41F IN COOLER.
- General violation description:
- 3-501.16 - Except during preparation, cooking, or cooling, or when time is used as the public health control as specified under 3-501.19, POTENTIALLY HAZARDOUS FOOD shall be maintained: (A) At 60C (140F) or above, except that roasts cooked to a temperature and for a time specified under 3-401.11(B) or reheated as specified in 3-403.11(E) may be held at a temperature of 54C (1300F)
|
10/09/2013 | Follow-up |
- Critical: Potentially Hazardous Food (Ti
- Items:
- Cold food item(s)
- Problems:
- Stored above 41 degrees f
- Corrections:
- Store below 41 degrees F.
- Comment:
- OBSERVED CHICKEN STRIPS 52F AND ROAST BEEF AND COLD CUT AT 49F. HOLD AT/BELOW 41F. CORRECT TODAY - END OF TODAY. FOLLOW UP IN 1-5 DAYS. RECOMMENDED TO CLOSE COOLER LID BETWEEN CUSTOMERS - LOWER LEVEL OF PRODUCT IN WELLS. PROVIDE WELL LIDS.,
- General violation description:
- 3-501.16 - Except during preparation, cooking, or cooling, or when time is used as the public health control as specified under 3-501.19, POTENTIALLY HAZARDOUS FOOD shall be maintained: (A) At 60C (140F) or above, except that roasts cooked to a temperature and for a time specified under 3-401.11(B) or reheated as specified in 3-403.11(E) may be held at a temperature of 54C (1300F)
|
09/10/2013 | Routine |
| No violation noted during this evaluation. | 09/26/2012 | Follow-up |
- Critical: Backflow prevention
- Items:
- Backflow/backsiphonage prevention device(s)
- Problems:
- Not provided on
- Corrections:
- Provide adequate air gap.
- Comment:
- PLASTIC CUP ATTACHED TO DRAIN LINE FROM THREE COMPARTMENT SINK. PROVIDE AIR GAP.
- General violation description:
- 5-402.11 - (A) Except as specified in (B) and (C) of this section, a direct connection may not exist between the SEWAGE system and a drain originating from EQUIPMENT in which FOOD, portable EQUIPMENT, or UTENSILS are placed. (B) If allowed by LAW, a WAREWASHING machine may have a direct connection between its waste outlet and a floor drain when the machine is located within 1.5 m (5 feet) of a trapped floor drain and the machine outlet is connected to the inlet side of a properly vented floor drain trap. (C) If allowed by LAW, a WAREWASHING or culinary sink may have a direct connection.
- Critical: Frequency Before Use After Cle
- Items:
- Clean utensil(s) and food-contact surface(s)
- Problems:
- Not sanitized
- Corrections:
- Sanitize as required above.
- Comment:
- THREE COMPARTMENT SINK LACKING SANITIZER. SANITIZER CONTAINER EMPTY.
- General violation description:
- 4-702.11 - UTENSILS and FOOD-CONTACT SURFACES of EQUIPMENT shall be SANITIZED before use after cleaning.
- Critical: Hot and cold holding
- Items:
- Hot food item(s)
- Problems:
- Stored below 135 degrees F
- Corrections:
- Store above 135 degrees F.
- Comment:
- MEAT BALLS 80F. IN HOT HOLDING UNIT.
- General violation description:
- 3-501.16 - Except during preparation, cooking, or cooling, or when time is used as the public health control as specified under 3-501.19, POTENTIALLY HAZARDOUS FOOD shall be maintained: (A) At 60C (140F) or above, except that roasts cooked to a temperature and for a time specified under 3-401.11(B) or reheated as specified in 3-403.11(E) may be held at a temperature of 54C (1300F)
|
09/19/2012 | Routine |
- Critical: Clean Sight/Touch-No Accum/Enc
- Comment:
- INTERIOR OF MICROWAVE OVEN IS CLEAN.
- General violation description:
- 4-601.11 - (A) EQUIPMENT FOOD-CONTACT SURFACES and UTENSILS shall be clean to sight and touch. (B) The FOOD-CONTACT SURFACES of cooking EQUIPMENT and pans shall be kept free of encrusted grease deposits and other soil accumulations. N (C) NonFOOD-CONTACT SURFACES of EQUIPMENT shall be kept free of an accumulation of dust, dirt, FOOD residue, and other debris. N
- Critical: Hot and cold holding
- Comment:
- MEAT BALL ARE 166F IN STEAM TABLE.
- General violation description:
- 3-501.16 - Except during preparation, cooking, or cooling, or when time is used as the public health control as specified under 3-501.19, POTENTIALLY HAZARDOUS FOOD shall be maintained: (A) At 60C (140F) or above, except that roasts cooked to a temperature and for a time specified under 3-401.11(B) or reheated as specified in 3-403.11(E) may be held at a temperature of 54C (1300F)
- Critical: Reheating for Hot Holding
- Comment:
- MEAT BALLS REHEATED TO 168F.
- General violation description:
- 3-403.11 - (A) Except as specified under (B) and (C) and in (E) of this section, POTENTIALLY HAZARDOUS FOOD that is cooked, cooled, and reheated for hot holding shall be reheated so that all parts of the FOOD reach a temperature of at least 74C (165F) for 15 seconds. (B) Except as specified under (C) of this section, POTENTIALLY HAZARDOUS FOOD reheated in a microwave oven for hot holding shall be reheated so that all parts of the FOOD reach a temperature of at least 74C (165F) and the FOOD is rotated or stirred, covered, and allowed to stand covered for 2 minutes after reheating. (C) READY-TO-EAT FOOD taken from a commercially processed, HERMETICALLY SEALED CONTAINER, or from an intact package from a FOOD PROCESSING PLANT that is inspected by the FOOD REGULATORY AUTHORITY that has jurisdiction over the plant, shall be heated to a temperature of at least 60C (140F) for hot holding. (D) Reheating for hot holding shall be done rapidly and the time the FOOD is between the temperature specified under 3-501.16(B) or (C) and 74C (165F) may not exceed 2 hours. (E) Remaining unsliced portions of roasts of beef that are cooked as specified under 3-401.11(B) may be reheated for hot holding using the oven parameters and minimum time and temperature conditions specified under 3-401.11(B).
|
09/16/2011 | Follow-up |
- Critical: Backflow prevention
- Items:
- Backflow/backsiphonage prevention device(s)
- Problems:
- Not provided on
- Corrections:
- Provide adequate air gap.
- Comment:
- CURRENTLY A LARGE CUP IS ATTACHED TO DRAIN LINE FROM THE THREE COMPARTMENT SINK. PROVIDE AN AIR GAP., THIS WAS CORRECTED BY REMOVING THE CUP FROM DRAIN LINE.
- General violation description:
- 5-402.11 - (A) Except as specified in (B) and (C) of this section, a direct connection may not exist between the SEWAGE system and a drain originating from EQUIPMENT in which FOOD, portable EQUIPMENT, or UTENSILS are placed. (B) If allowed by LAW, a WAREWASHING machine may have a direct connection between its waste outlet and a floor drain when the machine is located within 1.5 m (5 feet) of a trapped floor drain and the machine outlet is connected to the inlet side of a properly vented floor drain trap. (C) If allowed by LAW, a WAREWASHING or culinary sink may have a direct connection.
- Critical: Clean Sight/Touch-No Accum/Enc
- Items:
- Food-contact surface(s)
- Problems:
- Soiled
- Corrections:
- Keep clean.
- Comment:
- INTERIOR OF MICROWAVE OVEN SOILED. CLEAN AND MAINTAIN.,
- General violation description:
- 4-601.11 - (A) EQUIPMENT FOOD-CONTACT SURFACES and UTENSILS shall be clean to sight and touch. (B) The FOOD-CONTACT SURFACES of cooking EQUIPMENT and pans shall be kept free of encrusted grease deposits and other soil accumulations. N (C) NonFOOD-CONTACT SURFACES of EQUIPMENT shall be kept free of an accumulation of dust, dirt, FOOD residue, and other debris. N
- Critical: Frequency Before Use After Cle
- Items:
- Clean utensil(s) and food-contact surface(s)
- Problems:
- Not sanitized
- Corrections:
- Sanitize as required above.
- Comment:
- IMPROPER PROCEDURES USED TO SANITIZE EQUIPMENT. WASH, RINSE AND SANITIZE. , THIS WAS CORRECTED BY EDUCATING EMPLOYEES.
- General violation description:
- 4-702.11 - UTENSILS and FOOD-CONTACT SURFACES of EQUIPMENT shall be SANITIZED before use after cleaning.
- Critical: Hot and cold holding
- Items:
- Hot food item(s)
- Problems:
- Stored below 135 degrees F
- Corrections:
- Store above 135 degrees F.
- Comment:
- MEAT BALLS WERE IN HOT HOLDING UNIT AT 88F. STORE AT OR ABOVE 135F.,
- General violation description:
- 3-501.16 - Except during preparation, cooking, or cooling, or when time is used as the public health control as specified under 3-501.19, POTENTIALLY HAZARDOUS FOOD shall be maintained: (A) At 60C (140F) or above, except that roasts cooked to a temperature and for a time specified under 3-401.11(B) or reheated as specified in 3-403.11(E) may be held at a temperature of 54C (1300F)
- Critical: Reheating for Hot Holding
- Items:
- Microwave reheated food(s)
- Problems:
- Reheated to less than 165 degrees f
- Corrections:
- Reheat to 165 degrees F for 15 seconds.
- Comment:
- MEAT BALLS REHEATED TO 155F. CHANGE PROCEDURE TO RE HEAT TO 165F.,
- General violation description:
- 3-403.11 - (A) Except as specified under (B) and (C) and in (E) of this section, POTENTIALLY HAZARDOUS FOOD that is cooked, cooled, and reheated for hot holding shall be reheated so that all parts of the FOOD reach a temperature of at least 74C (165F) for 15 seconds. (B) Except as specified under (C) of this section, POTENTIALLY HAZARDOUS FOOD reheated in a microwave oven for hot holding shall be reheated so that all parts of the FOOD reach a temperature of at least 74C (165F) and the FOOD is rotated or stirred, covered, and allowed to stand covered for 2 minutes after reheating. (C) READY-TO-EAT FOOD taken from a commercially processed, HERMETICALLY SEALED CONTAINER, or from an intact package from a FOOD PROCESSING PLANT that is inspected by the FOOD REGULATORY AUTHORITY that has jurisdiction over the plant, shall be heated to a temperature of at least 60C (140F) for hot holding. (D) Reheating for hot holding shall be done rapidly and the time the FOOD is between the temperature specified under 3-501.16(B) or (C) and 74C (165F) may not exceed 2 hours. (E) Remaining unsliced portions of roasts of beef that are cooked as specified under 3-401.11(B) may be reheated for hot holding using the oven parameters and minimum time and temperature conditions specified under 3-401.11(B).
- Cleaning, Frequency/Restrictio
- Items:
- Physical facilities/structures
- Problems:
- With accumulation of debris
- Corrections:
- Keep clean.
- Comment:
- WALK IN COOLER FLOOR SOILED UNDER EQUIPMENT. CLEAN AND MAINTAIN.
- General violation description:
- 6-501.12 - (A) PHYSICAL FACILITIES shall be cleaned as often as necessary to keep them clean. (B) Except for cleaning that is necessary due to a spill or other accident, cleaning shall be done during periods when the least amount of FOOD is exposed such as after closing.
- Duties of Person in Charge
- Items:
- Person-in-charge
- Problems:
- Does not demonstrate required knowledge
- Corrections:
- Knowledge is to be obtained through an approved training program.
- Comment:
- MANAGER DID NOT KNOW HOW TO TEST SANITIZER LEVEL IN THREE COMPARTMENT SINK. ALSO, OWNER MR. PATEL DID NOT KNOW PROPER RE-HEATING TEMPERATURE OF MEAT BALLS IN MICROWAVE OVEN. TRAIN EMPLOYEES AS NEEDED.
- General violation description:
- 2-103.11 - The PERSON IN CHARGE shall ensure that: (A) FOOD ESTABLISHMENT operations are not conducted in a private home or in a room used as living or sleeping quarters as specified under # 6-202.111
- Hair Restraint Effectiveness
- Items:
- Hair restraint
- Problems:
- Not worn on head/hair
- Corrections:
- Provide hat or hair net.
- General violation description:
- 2-402.11 - (A) Except as provided in # (B) of this section, FOOD EMPLOYEES shall wear hair restraints such as hats, hair coverings or nets, beard restraints, and clothing that covers body hair, that are designed and worn to effectively keep their hair from contacting exposed FOOD
|
09/08/2011 | Routine Inspection |
- Hair Restraint Effectiveness
- Items:
- Hair restraint
- Problems:
- Not worn on head/hair
- Corrections:
- Provide hat or hair net.
- Comment:
- EMPLOYEES MUST WEAR HATS OR HAIRNETS TO COVER HAIR WHILE WORKING WITH FOOD.
- General violation description:
- 2-402.11 - (A) Except as provided in # (B) of this section, FOOD EMPLOYEES shall wear hair restraints such as hats, hair coverings or nets, beard restraints, and clothing that covers body hair, that are designed and worn to effectively keep their hair from contacting exposed FOOD
- Outer Openings, Protected
- Items:
- Outer opening(s)
- Locations:
- BACK DOOR
- Problems:
- Not sealed to prevent pest entry
- Corrections:
- Seal to prevent pest entry.
- Comment:
- PROVIDE NEW WEATHERSTRIPPING FOR BACK DOOR WHERE IT IS BROKEN TO PREVENT PEST ENTRY.
- General violation description:
- 6-202.15 - (A) Except as specified in ## (B), (C), and (E) and under # (D) of this section, outer openings of a FOOD ESTABLISHMENT shall be protected against the entry of insects and rodents by: (1) Filling or closing holes and other gaps along floors, walls, and ceilings
|
09/22/2010 | Routine Inspection |
- Storing Equip./Uten./Lin./Sing
- Items:
- Single-service/single-use article(s)
- Problems:
- Exposed to dust, splash, or other contaminates
- Corrections:
- Store in protected manner.
- Comment:
- SINGLE USE ITEMS STORED UNDER THE DRAIN SYSTEM UNDER THE COUNTERS BUT GOT RELOCATED DURING THE VISIT. VIOLATION CORRECTED.
- General violation description:
- 4-903.11 - (A) Except as specified in # (D) of this section, cleaned EQUIPMENT and UTENSILS, laundered LINENS, and SINGLE-SERVICE and SINGLE-USE ARTICLES shall be stored: (1) In a clean, dry location
|
09/14/2009 | Routine Inspection |
- Cleaning, Frequency/Restrictio
- Items:
- Physical facilities/structures
- Locations:
- Dining area ceiling vents
- Problems:
- Soiled
- Corrections:
- Keep clean.
- Comment:
- OUTLET VENTS.
- General violation description:
- 6-501.12 - (A) PHYSICAL FACILITIES shall be cleaned as often as necessary to keep them clean. (B) Except for cleaning that is necessary due to a spill or other accident, cleaning shall be done during periods when the least amount of FOOD is exposed such as after closing.
- Drying mops
- Items:
- Wet mop(s) storage
- Locations:
- Mop sink(s)
- Problems:
- Improperly dried
- Corrections:
- Allow to air dry in an approved location.
- General violation description:
- 6-501.16 - After use, mops shall be placed in a position that allows them to air-dry without soiling walls, EQUIPMENT, or supplies.
|
03/19/2009 | Routine Inspection |
- Cleaning, Frequency/Restrictio
- Items:
- Physical facilities/structures
- Locations:
- ceiling vents
- Problems:
- With accumulation of debris
- Corrections:
- Keep clean.
- Comment:
- OUTLET VENTS ONLY.
- General violation description:
- 6-501.12 - (A) PHYSICAL FACILITIES shall be cleaned as often as necessary to keep them clean. (B) Except for cleaning that is necessary due to a spill or other accident, cleaning shall be done during periods when the least amount of FOOD is exposed such as after closing.
- Repairing
- Items:
- Physical facilities
- Locations:
- walk-in cooler(s) coving / wall edging
- Problems:
- In poor repair
- Corrections:
- Repair/replace.
- General violation description:
- 6-501.11 - PHYSICAL FACILITIES shall be maintained in good repair.
- Temperature Measuring Devices
- Items:
- Thermometer(s)
- Locations:
- 1-door refrigerator(s)
- Problems:
- Not provided
- Corrections:
- Provide.
- General violation description:
- 4-204.112 - (A) In a mechanically refrigerated or hot FOOD storage unit, the sensor of a TEMPERATURE MEASURING DEVICE shall be located to measure the air temperature or a simulated product temperature in the warmest part of a mechanically refrigerated unit and in the coolest part of a hot FOOD storage unit. (B) Except as specified in # (C) of this section, cold or hot holding EQUIPMENT used for POTENTIALLY HAZARDOUS FOOD (TIME/TEMPERATURE CONTROL FOR SAFETY FOOD) shall be designed to include and shall be equipped with at least one integral or permanently affixed TEMPERATURE MEASURING DEVICE that is located to allow easy viewing of the device's temperature display. (C) Paragraph (B) of this section does not apply to EQUIPMENT for which the placement of a TEMPERATURE MEASURNG DEVICE is not a practical means for measuring the ambient air surrounding the FOOD because of the design, type, and use of the EQUIPMENT, such as calrod units, heat lamps, cold plates, bainmaries, steam tables, insulated FOOD transport containers, and salad bars. (D) TEMPERATURE MEASURING DEVICES shall be designed to be easily readable. (E) FOOD TEMPERATURE MEASURING DEVICES and water TEMPERATURE MEASURING DEVICES on WAREWASHING machines shall have a numerical scale, printed record, or digital readout in increments no greater than 1°C or 2°F in the intended range of use.(Pf)
|
10/07/2008 | Routine Inspection |
Restaurant representatives - add corrected or new information about Subway, 23764 West, Brownstown, MI 48134 »